Sony CDX-S2010 Service Manual
Hide thumbs
Also See for CDX-S2010:
- User manual ,
- Operating instructions manual (24 pages) ,
- Installation/connections (2 pages)
Table of Contents
Advertisement
SERVICE MANUAL
Ver. 1.3 2006.05
• The tuner and CD sections have no adjustments.
AUDIO POWER SPECIFICATIONS (US Model)
POWER OUTPUT AND TOTAL HARMONIC DISTORTION
23.2 watts per channel minimum continuous average power into
4 ohms, 4 channels driven from 20 Hz to 20 kHz with no more
than 5% total harmonic distortion.
CD player section
Signal-to-noise ratio
120 dB
Frequency response
10 – 20,000 Hz
Wow and flutter
Below measurable limit
Tuner section
FM
Tuning range
US, Canadian Model:
87.5 – 107.9 MHz
AEP, UK, E model:
FM tuning interval:
50 kHz/200 kHz
switchable
87.5 – 108 MHz (at 50 kHz step)
87.5 – 107.9 MHz (at 200 kHz step)
East European Model:
FM1/FM2: 87.5 – 108.0 MHz (at 50 kHz step)
FM3: 65 – 74 MHz (at 30 kHz step)
Antenna terminal
External antenna connector
Intermediate frequency 10.7 MHz/450 kHz
Usable sensitivity
9 dBf
Selectivity
75 dB at 400 kHz
Signal-to-noise ratio
67 dB (stereo),
69 dB (mono)
Harmonic distortion at 1 kHz
0.5% (stereo),
0.3% (mono)
Separation
35 dB at 1 kHz
Frequency response
30 – 15,000 Hz
Sony Corporation
9-879-305-04
2006E04-1
eVehicle Division
© 2006.05
Published by Sony Techno Create Corporation
CDX-S2010/S2010C/S2010T/
Model Name Using Similar Mechanism
CD Drive Mechanism Type
Optical Pick-up Name
SPECIFICATIONS
AM
Tuning range
Antenna terminal
Intermediate frequency 10.7 MHz/450 kHz
Sensitivity
Power amplifier section
Outputs
Speaker impedance
Maximum power output 52 W × 4 (at 4 ohms)
General
Outputs
Inputs
Tone controls
FM/AM COMPACT DISC PLAYER
S2010X/S2050EE
Canadian Model
AEP Model
CDX-S2010C/S2010T/S2010X
East European Model
US, Canadian Model:
530 – 1,710 kHz
AEP, UK, E Model:
AM tuning interval:
9 kHz/10 kHz switchable
531 – 1,602 kHz (at 9 kHz step)
530 – 1,710 kHz (at 10 kHz step)
East European Model:
531 – 1,602 kHz
External antenna connector
30 µV
Speaker outputs
(sure seal connectors)
4 – 8 ohms
Audio outputs terminal (sub/rear switchable)
Power antenna relay control terminal
Power amplifier control terminal
Antenna input terminal
Remote controller input terminal (CDX-S2010C only)
Low: ±10 dB at 60 Hz (XPLOD)
Mid: ±10 dB at 1 kHz (XPLOD)
High: ±10 dB at 10 kHz (XPLOD)
– Continued on next page –
US Model
CDX-S2010
UK Model
CDX-S2010T
E Model
CDX-S2050EE
NEW
MG-611XE-186//K
KSS1000E
1
Advertisement
Chapters
Table of Contents
Related Manuals for Sony CDX-S2010
Summary of Contents for Sony CDX-S2010
- Page 1 35 dB at 1 kHz High: ±10 dB at 10 kHz (XPLOD) Frequency response 30 – 15,000 Hz – Continued on next page – FM/AM COMPACT DISC PLAYER Sony Corporation 9-879-305-04 2006E04-1 eVehicle Division © 2006.05 Published by Sony Techno Create Corporation...
- Page 2 NE REMPLACER CES COMPOSANTS QUE PAR DES PIÈCES REPLACE THESE COMPONENTS WITH SONY PARTS WHOSE SONY DONT LES NUMÉROS SONT DONNÉS DANS CE MANUEL PART NUMBERS APPEAR AS SHOWN IN THIS MANUAL OR OU DANS LES SUPPLÉMENTS PUBLIÉS PAR SONY.
- Page 3 CDX-S2010/S2010C/S2010T/S2010X/S2050EE Notes on CD-DA/CD-R/CD-RW UNLEADED SOLDER • CD playback: Boards requiring use of unleaded solder are printed with the lead You can play CD-DA and CD-R/CD-RW for audio use. free mark (LF) indicating the solder contains no lead. (Caution: Some printed circuit boards may not come printed with the lead free mark due to their particular size.)
-
Page 4: Table Of Contents
CDX-S2010/S2010C/S2010T/S2010X/S2050EE TABLE OF CONTENTS 1. GENERAL Location of controls and basic operations (US, Canadian Model) ............. 5 Location of controls and basic operations (East European Model) ............5 Location of controls and basic operations (E Model) ..... 5 Connections (US, Canadian Model) ........6 Connections (E Model) ............ -
Page 5: General
CDX-S2010/S2010C/S2010T/S2010X/S2050EE SECTION 1 GENERAL This section is extracted from instruction manual. Location of controls and basic operations Location of controls and basic operations (US, Canadian Model) (E Model) Main unit Main unit 2 3 4 7 8 9 2 3 4... -
Page 6: Connections (Us, Canadian Model)
CDX-S2010/S2010C/S2010T/S2010X/S2050EE Connections (US, Canadian Model) RCA pin cord (not supplied) AUDIO OUT can be switched to SUB or REAR. For details, see the supplied operating instructions. Cordon à broche RCA (non fourni) AUDIO OUT peut être commuté sur SUB ou REAR. -
Page 7: Connections (E Model)
CDX-S2010/S2010C/S2010T/S2010X/S2050EE Connections (E Model) -
Page 8: Connections (East European Model)
CDX-S2010/S2010C/S2010T/S2010X/S2050EE Connections (East European Model) -
Page 9: Disassembly
CDX-S2010/S2010C/S2010T/S2010X/S2050EE SECTION 2 DISASSEMBLY Note : This set can be disassemble according to the following sequence. 2-1. SUB PANEL (LCD) ASSY (Page 10) 2-2. CD MECHANISM BLOCK (Page 10) 2-10. SERVO BOARD 2-3. MAIN BOARD 2-4. CHASSIS (T) SUB ASSY... -
Page 10: Sub Panel (Lcd) Assy
CDX-S2010/S2010C/S2010T/S2010X/S2050EE Note : Follow the disassembly procedure in the numerical order given. 2-1. SUB PANEL (LCD) ASSY 3 two claws 2 two claws 1 two screws (+PTT 2.6 x 6) 4 sub panel (LCD) assy 2-2. CD MECHANISM BLOCK 7 bracket (CD) -
Page 11: Main Board
CDX-S2010/S2010C/S2010T/S2010X/S2050EE 2-3. MAIN BOARD 1 three screws (+BTT) 2 two screws (+PTT 2.6 x 8) 3 MAIN board 4 insulating sheet 2-4. CHASSIS (T) SUB ASSY 4 claw 2 two screws (+P 1.7 x 2.2) 1 two screws (+P 1.7 x 2.2) -
Page 12: Roller Arm Assy
CDX-S2010/S2010C/S2010T/S2010X/S2050EE 2-5. ROLLER ARM ASSY 3 washer (1.1-2.5) 5 roller arm assy 4 gear (RA1) 2 spring (RAR) 1 spring (RAL) 2-6. CHASSIS (OP) ASSY qa chassis (OP) assy 0 coil spring (damper) lever (D) 4 washer 1 CN2 (16P) -
Page 13: Optical Pick-Up
CDX-S2010/S2010C/S2010T/S2010X/S2050EE 2-7. OPTICAL PICK-UP 2 chucking arm sub assy 5 claw 1 tension coil spring (CHKG) 7 optical pick-up 6 main shaft 4 rack (SL) 3 screw (+B 1.4 x 5) 2-8. SL MOTOR ASSY (M902) 1 screw (+P 1.4 x 1.8) -
Page 14: Le Motor Assy (M903)
CDX-S2010/S2010C/S2010T/S2010X/S2050EE 2-9. LE MOTOR ASSY (M903) 8 screw 0 gear (LE) assy (+M 1.7 x 2.5) 9 bearing (LEB-N) 2 washer qa screw (+M 1.7 x 2.5) qf two toothed lock screws 3 gear (LE1) (+M 1.4 ) lever (D) -
Page 15: Diagrams
CDX-S2010/S2010C/S2010T/S2010X/S2050EE SECTION 3 DIAGRAMS 3-1. BLOCK DIAGRAM – CD SECTION – • R-ch is omitted due to same as L-ch. • Siganal Path : CD PLAY DETECTOR MAIN AGCO 77 AGCI 71 RFI 69 ASY LOUT CD-L SECTION (Page 16) -
Page 16: Block Diagram - Main Section
CDX-S2010/S2010C/S2010T/S2010X/S2050EE 3-2. BLOCK DIAGRAM – MAIN SECTION – ELECTRONIC VOLUME IC401 CD-L 9 CD LCH SECTION J330 OUT SUB-L R-CH 8 CD RCH (Page 15) AUDIO OUT OUT SUB-R R-CH R-CH POWER AMP, POWER SUPPLY MUTE IC750 (TUNER UNIT) Q481... -
Page 17: Block Diagram - Display Section
CDX-S2010/S2010C/S2010T/S2010X/S2050EE • Circuit Boards Location 3-3. BLOCK DIAGRAM – DISPLAY SECTION – SYSTEM CONTROL LCD DRIVER IC501 (3/3) IC901 KEYIN0 KEY MATRIX LSW901-921 LCD901 LCD SO KEYIN1 LCD CKO LIQUID • LCD CE CRYSTAL SERVO board D501 (1/2) EXCEPT DISPLAY... - Page 18 CDX-S2010/S2010C/S2010T/S2010X/S2050EE Ver. 1.3 • NOTE FOR PRINTED WIRING BOARDS AND SCHEMATIC DIAGRAMS • Waveforms — MAIN Board — — SERVO Board — THIS NOTE IS COMMON FOR PRINTED WIRING BOARDS AND SCHEMATIC DIAGRAMS. (In addition to this, the necessary note is printed IC501 i;...
-
Page 19: Printed Wiring Boards - Servo Board
CDX-S2010/S2010C/S2010T/S2010X/S2050EE 3-4. PRINTED WIRING BOARDS – SERVO BOARD – • See page 17 for Circuit Boards Location. : Uses unleaded solder. CDX-S2010/S2010C/S2010T/S2010X/S2050EE... -
Page 20: Schematic Diagram - Servo Board
CDX-S2010/S2010C/S2010T/S2010X/S2050EE 3-5. SCHEMATIC DIAGRAM – SERVO BOARD – • • • IC Pin Descriptions. See page 28 for IC Block Diagram. See page 18 for Waveforms. See page 30 for TP19 TP32 TP33 R14 R15 TP31 TP20 TP30 TP29 TP14... -
Page 21: Printed Wiring Board - Main Board
CDX-S2010/S2010C/S2010T/S2010X/S2050EE 3-6. PRINTED WIRING BOARD – MAIN BOARD – • See page 17 for Circuit Boards Location. : Uses unleaded solder. S2050EE S2010C,S2010T,S2010X • Semiconductor Location Ref. No. Location Ref. No. Location D762 (Page 19) D479 D763 D501 D764 EXCEPT S2010C... -
Page 22: Schematic Diagram - Main Board (1/4)
CDX-S2010/S2010C/S2010T/S2010X/S2050EE 3-7. SCHEMATIC DIAGRAM – MAIN BOARD (1/4) – • See page 28 for IC Block Diagram. J330 C484 C474 JC12 C432 R433 R432 R431 C431 IC401 JC401 Q431 R452 C401 C413 Q451 C451 R451 R453 C452 R405 C412 C404... -
Page 23: Schematic Diagram - Main Board (2/4)
CDX-S2010/S2010C/S2010T/S2010X/S2050EE 3-8. SCHEMATIC DIAGRAM – MAIN BOARD (2/4) – • See page 29 for IC Block Diagram. C775 C765 C764 C774 C776 D751 C751 IC B/D C752 D752 C750 D753 D754 JC754 JC755 D755 D756 IC750 CN601 D757 D758 D651... -
Page 24: Schematic Diagram - Main Board (3/4)
CDX-S2010/S2010C/S2010T/S2010X/S2050EE 3-9. SCHEMATIC DIAGRAM – MAIN BOARD (3/4) – • • IC Pin Descriptions. See page 18 for Waveforms. See page 32 for (Page 22) JC534 R564 R531 R519 R536 R535 R533 R556 R543 D502 R674 C509 X502 C507 JC501... -
Page 25: Schematic Diagram - Main Board (4/4)
CDX-S2010/S2010C/S2010T/S2010X/S2050EE 3-10. SCHEMATIC DIAGRAM – MAIN BOARD (4/4) – (Page 23) C759 CN701 FB603 R705 R706 R707 JC681 FB604 (Page 27) C771 IC602 C623 FB606 C761 R601 S702 C622 C519 JC506 FB605 D701 D702 (Page 24) R703 JW98 JW53 R652... -
Page 26: Printed Wiring Board - Key Board
CDX-S2010/S2010C/S2010T/S2010X/S2050EE 3-11. PRINTED WIRING BOARD – KEY BOARD – • See page 17 for Circuit Boards Location. : Uses unleaded solder. LSW905 LSW905 LSW901 LED952 LED952 LED951 LED951 LSW910 (DISC-R) (DISC-L) LSW901 R923 LSW906 LSW906 R933 R921 R922 LSW910,LED941 R955... -
Page 27: Schematic Diagram - Key Board
CDX-S2010/S2010C/S2010T/S2010X/S2050EE 3-12. SCHEMATIC DIAGRAM – KEY BOARD – JP935 LED951 LED952 LSW909(2/2) LSW904(2/2) R981 D902 CN901 LED941 R972 LSW902(2/2) LSW917(2/2) LSW907(2/2) R923 R982 R921 R929 R973 IC971 LED931 R931 R941 R949 R939 R924 R922 R930 R953 R951 R958 R925 R927... - Page 28 CDX-S2010/S2010C/S2010T/S2010X/S2050EE • IC Block Diagrams – SERVO Board – – MAIN Board – IC2 BA5966FP-FE2 IC401 BD3808FS-FE2 MUTE – – – – FADER FADER FADER FADER (0~-58, (0~-58, (0~-58, (0~-58, C BUS -∞dB) -∞dB) -∞dB) -∞dB) – GAIN+ATT – LOGIC...
- Page 29 CDX-S2010/S2010C/S2010T/S2010X/S2050EE IC750 TDA8588BJ/N2/R1 OUT-FL- C BUS OUT-FL+ OUT-RL- PGND3 OUT-RL+ IN-RL IN-FL S-GND PROTECTION/ DIAGNOSTIC IN-FR IN-RR BEEP OUT-RR+ PGND2 OUT-RR- OUT-FR+ STANDBY/ MUTE OUT-FR- CHIP DETECT/ PGND1 DIAGNOSTIC BATTERY TEMPERATURE DIAG DETECTION PROTECTION ENABLE LOGIC SWITCH ANT-REM CRES SWITCH AMP-REM AUDIO8.3V...
- Page 30 CDX-S2010/S2010C/S2010T/S2010X/S2050EE • IC Pin Descriptions IC1 µPD63712GC-8EU-A (RF AMP, DIGITAL SERVO, DIGITAL SIGNAL PROCESSOR) (SERVO BOARD) Pin No. Pin Name Pin Description Laser diode ON/OFF control signal output (L: laser OFF, H: laser ON) Dimmer monitor input from optical pick-up laser diode.
- Page 31 CDX-S2010/S2010C/S2010T/S2010X/S2050EE Pin No. Pin Name Pin Description LRCK Not used. (Connect to LRCKIN in this set) DVDD — Power supply pin (+3.3 V) Focus servo drive PWM signal output (+) FD– Focus servo drive PWM signal output (–) Tracking servo drive PWM signal output (+) TD–...
- Page 32 CDX-S2010/S2010C/S2010T/S2010X/S2050EE IC501 MB90488BPF-G-117-BNDE1 (SYSTEM CONTROL) (MAIN BOARD (3/4)) Pin No. Pin Name Pin Description AREA SEL2 Destination setting pin AREA SEL1 Destination setting pin AREA SEL0 Destination setting pin COL SW Illumination color select signal input BEEP Beep signal output...
- Page 33 CD INTQ CD text pack synchronized signal input DAVN RDS data block synchronized detect signal input Not used UNI SI SONY bus data input UNI SO SONY bus data output UNI SCK SONY bus clock output Not used Not used...
-
Page 34: Exploded Views
CDX-S2010/S2010C/S2010T/S2010X/S2050EE SECTION 4 EXPLODED VIEWS NOTE: • The mechanical parts with no reference • Color Indication of Appearance Parts The components identified by mark 0 or dotted line with mark number in the exploded views are not supplied. Example : 0 are critical for safety. -
Page 35: Front Panel Section
A-1083-284-A PANEL COMPLETE ASSY, FRONT (S2010T) X-2048-519-1 PANEL SUB ASSY, FRONT (S2010C) 3-250-543-31 SCREW (+B P-TITE M2) X-2048-520-1 PANEL SUB ASSY, FRONT (S2050EE) 3-251-320-01 EMBLEM (NO. 2.5), SONY X-2048-523-1 PANEL SUB ASSY, FRONT (S2010T) LCD901 1-805-728-21 DISPLAY PANEL, LIQUID CRYSTAL 2-187-737-01 PLATE (CD), LIGHT GUIDE... -
Page 36: Cd Mechanism Section (1) (Mg-611Xe-186//K)
CDX-S2010/S2010C/S2010T/S2010X/S2050EE 4-3. CD MECHANISM SECTION (1) (MG-611XE-186//K) not supplied (SENSOR board) not supplied not supplied not supplied not supplied Ref. No. Part No. Description Remark Ref. No. Part No. Description Remark A-3372-455-A CHASSIS (T) SUB ASSY 3-253-748-01 DAMPER (S) 3-253-729-01 SPRING (LTR), TENSION COIL 3-352-758-31 SCREW (M1.7), TOOTHED LOCK... -
Page 37: Cd Mechanism Section (2) (Mg-611Xe-186//K)
CDX-S2010/S2010C/S2010T/S2010X/S2050EE 4-4. CD MECHANISM SECTION (2) (MG-611XE-186//K) (including M901) M902 not supplied not supplied not supplied not supplied The components identified by mark 0 or dotted line with mark 0 are critical for safety. Replace only with part number specified. -
Page 38: Cd Mechanism Section (3) (Mg-611Xe-186//K)
CDX-S2010/S2010C/S2010T/S2010X/S2050EE 4-5. CD MECHANISM SECTION (3) (MG-611XE-186//K) M903 Ref. No. Part No. Description Remark Ref. No. Part No. Description Remark 3-262-755-01 WASHER (1.1-2.5) 2-186-696-11 BRACKET (LEM-N) 2-186-699-11 GEAR (RA1) 3-345-648-91 SCREW (M1.4), TOOTHED LOCK A-1075-789-A ARM ASSY, ROLLER A-1083-637-A GEAR (LE) ASSY... -
Page 39: Cd Mechanism Section (4) (Mg-611Xe-186//K)
CDX-S2010/S2010C/S2010T/S2010X/S2050EE 4-6. CD MECHANISM SECTION (4) (MG-611XE-186//K) Ref. No. Part No. Description Remark Ref. No. Part No. Description Remark 2-186-700-11 GEAR (CHK1) 3-899-829-01 WASHER (SLIT) 3-344-223-01 WASHER 3-259-032-01 GEAR (LE2) 3-259-470-01 GEAR (LE1) A-1075-791-A CHASSIS (M) BLOCK ASSY 3-253-755-02 LEVER (D) -
Page 40: Electrical Parts List
CDX-S2010/S2010C/S2010T/S2010X/S2050EE SECTION 5 ELECTRICAL PARTS LIST NOTE: • Due to standardization, replacements in • Items marked “*” are not stocked since The components identified by mark 0 or dotted line with mark the parts list may be different from the they are seldom required for routine service. - Page 41 CDX-S2010/S2010C/S2010T/S2010X/S2050EE Ref. No. Part No. Description Remark Ref. No. Part No. Description Remark LSW906 1-786-800-11 SWITCH, TACTILE (WITH LED) (VOL +) LSW918 1-786-805-11 SWITCH, TACTILE (WITH LED) (2/GROUP +) (S2010/S2010T/S2010X) (S2010/S2010T/S2010X) LSW906 1-786-801-11 SWITCH, TACTILE (WITH LED) (VOL +) LSW918 1-786-806-11 SWITCH, TACTILE (WITH LED) (2/GROUP +)
- Page 42 CDX-S2010/S2010C/S2010T/S2010X/S2050EE Ref. No. Part No. Description Remark Ref. No. Part No. Description Remark R924 1-216-809-11 METAL CHIP 1/10W R944 1-216-807-11 METAL CHIP 1/10W (S2010C) (S2010/S2010T/S2010X) R945 1-216-807-11 METAL CHIP 1/10W R925 1-216-807-11 METAL CHIP 1/10W (S2010C) (S2050EE) R946 1-216-805-11 METAL CHIP...
- Page 43 CDX-S2010/S2010C/S2010T/S2010X/S2050EE MAIN Ref. No. Part No. Description Remark Ref. No. Part No. Description Remark R968 1-216-808-11 METAL CHIP 1/10W C451 1-126-964-11 ELECT 10uF (S2010/S2010T/S2010X) C452 1-107-823-11 CERAMIC CHIP 0.47uF R969 1-216-804-11 METAL CHIP 1/10W C461 1-126-964-11 ELECT 10uF (S2010C) C462 1-107-823-11 CERAMIC CHIP 0.47uF...
- Page 44 CDX-S2010/S2010C/S2010T/S2010X/S2050EE MAIN Ref. No. Part No. Description Remark Ref. No. Part No. Description Remark < DIODE > < JACK > 8-719-069-55 DIODE UDZSTE-175.6B 1-815-185-13 JACK (ANTENNA) D479 8-719-988-61 DIODE 1SS355TE-17 J330 1-774-698-11 JACK, PIN 2P (AUDIO OUT) D501 8-719-914-44 DIODE DAP202K (S2010C)
- Page 45 CDX-S2010/S2010C/S2010T/S2010X/S2050EE MAIN Ref. No. Part No. Description Remark Ref. No. Part No. Description Remark R401 1-216-797-11 METAL CHIP 1/10W R534 1-216-833-11 METAL CHIP 1/10W R535 1-216-845-11 METAL CHIP 100K 1/10W R405 1-218-881-11 METAL CHIP 0.5% 1/10W R536 1-216-845-11 METAL CHIP...
- Page 46 CDX-S2010/S2010C/S2010T/S2010X/S2050EE MAIN SENSOR SERVO Ref. No. Part No. Description Remark Ref. No. Part No. Description Remark R651 1-216-821-11 METAL CHIP 1/10W 1-107-826-11 CERAMIC CHIP 0.1uF (S2050EE) 1-162-970-11 CERAMIC CHIP 0.01uF R652 1-216-841-11 METAL CHIP 1/10W 1-107-826-11 CERAMIC CHIP 0.1uF (S2050EE)
- Page 47 CDX-S2010/S2010C/S2010T/S2010X/S2050EE SERVO Ref. No. Part No. Description Remark Ref. No. Part No. Description Remark 1-216-809-11 METAL CHIP 1/10W ACCESSORIES 1-216-809-11 METAL CHIP 1/10W ************ 1-216-833-11 METAL CHIP 1/10W 2-348-403-11 MANUAL, INSTRUCTION (ENGLISH, FRENCH) 1-216-840-11 METAL CHIP 1/10W (S2010) 1-414-760-21 FERRITE, EMI (SMD) (1608)
- Page 48 CDX-S2010/S2010C/S2010T/S2010X/S2050EE MEMO...
- Page 49 CDX-S2010/S2010C/S2010T/ S2010X/S2050EE US Model Canadian Model SERVICE MANUAL CDX-S2010 AEP Model UK Model Ver. 1.3 2006.05 CDX-S2010T E Model SUPPLEMENT-1 CDX-S2010C/S2010T/S2010X East European Model File this supplement with the service manual. CDX-S2050EE Subject : Production country change and AEP, UK model Addition of CDX-S2010T.
- Page 50 CDX-S2010/S2010C/S2010T/S2010X/S2050EE TABLE OF CONTENTS 1. DIAGRAMS 1-1. Printed Wiring Boards –CD Mechanism Section– ....4 1-2. Schematic Diagram –CD Mechanism Section– ....5 1-3. Printed Wiring Board –Main Section– ........ 6 1-4. Schematic Diagram –Main Section (1/3)– ......7 1-5. Schematic Diagram –Main Section (2/3)– ......8 1-6.
-
Page 51: Diagrams
CDX-S2010/S2010C/S2010T/S2010X/S2050EE Ver. 1.3 SECTION 1 DIAGRAMS • NOTE FOR PRINTED WIRING BOARDS AND SCHEMATIC DIAGRAMS • WAVEFORMS THIS NOTE IS COMMON FOR PRINTED WIRING — SERVO BOARD — — MAIN BOARD — BOARDS AND SCHEMATIC DIAGRAMS. (CD PLAY) (In addition to this, the necessary note is printed IC501 ul (XIN) in each block.) -
Page 52: Printed Wiring Boards -Cd Mechanism Section
CDX-S2010/S2010C/S2010T/S2010X/S2050EE 1-1. PRINTED WIRING BOARDS — CD MECHANISM SECTION — : Uses unleaded solder. (Page 6) CDX-S2010/S2010C/S2010T/S2010X/S2050EE... - Page 53 CDX-S2010/S2010C/S2010T/S2010X/S2050EE • Refer to page 3 for Waveforms. 1-2. SCHEMATIC DIAGRAM — CD MECHANISM SECTION — • Refer to page 10 for IC Block Diagrams. TP19 TP32 TP33 R14 R15 TP31 TP20 TP30 TP29 TP14 TP21 TP28 TP27 TP26 TP13...
-
Page 54: Printed Wiring Board -Main Section
CDX-S2010/S2010C/S2010T/S2010X/S2050EE 1-3. PRINTED WIRING BOARD — MAIN SECTION — : Uses unleaded solder. J330 US,CND,E,MODEL JC12 CN601 C484 C474 C776 C775 C774 JW144 JW154 C751 R482 R442 R472 R432 C771 IC750 C764 C765 C763 JC754 JW14 JC446 C617 C442 JC445... -
Page 55: Schematic Diagram -Main Section (1/3)
CDX-S2010/S2010C/S2010T/S2010X/S2050EE 1-4. SCHEMATIC DIAGRAM — MAIN SECTION (1/3) — • Refer to page 10 for IC Block Diagrams. J330 C484 C474 JC12 R433 C432 JC401 C431 R431 Q431 R432 C401 C413 R452 Q451 C451 R451 R453 C452 R405 C412 C404... -
Page 56: Schematic Diagram -Main Section (2/3)
CDX-S2010/S2010C/S2010T/S2010X/S2050EE 1-5. SCHEMATIC DIAGRAM — MAIN SECTION (2/3) — • Refer to page 11 for IC Block Diagrams. US,CND,E MODEL C775 C765 C764 C774 C776 C751 D751 C752 D752 C750 D753 IC B/D D754 JC754 D755 JC755 D756 IC750 AEP,UK MODEL... -
Page 57: Schematic Diagram -Main Section (3/3)
CDX-S2010/S2010C/S2010T/S2010X/S2050EE 1-6. SCHEMATIC DIAGRAM — MAIN SECTION (3/3) — • Refer to page 3 for Waveforms. (Page 8) (Page 7) FB604 JC681 JC534 R531 FB606 R556 R533 R519 R536 R535 JC506 FB605 C623 R601 C622 IC602 C519 S702 R674 C509... - Page 58 CDX-S2010/S2010C/S2010T/S2010X/S2050EE • IC BLOCK DIAGRAMS IC2 BA5966FP-FE2 (SERVO Board) IC401 BD3806FS-FE2 (MAIN Board (1/3)) MUTE – – – – FADER FADER FADER FADER (0~-58, (0~-58, (0~-58, (0~-58, C BUS – -∞dB) -∞dB) -∞dB) -∞dB) GAIN+ATT LOGIC – LEVEL (+10~-29, SHIFT –...
- Page 59 CDX-S2010/S2010C/S2010T/S2010X/S2050EE IC750 TDA8588BJ/N2/R1 (MAIN Board (2/3)) OUT FL- I2C BUS OUT FL+ OUT RL- PGND3 OUT RL+ INRL INFL SGND PROTECTION DIAGNOSTIC INFR INRR AC GND OUT RR+ PGND2 OUT RR- OUT FR+ STANDBY MUTE OUT FR- CHIP DETECT DIAGNOSTIC...
-
Page 60: Exploded Views
CDX-S2010/S2010C/S2010T/S2010X/S2050EE SECTION 2 EXPLODED VIEWS NOTE: • The mechanical parts with no reference • Color Indication of Appearance Parts The components identified by mark 0 or dotted line with mark number in the exploded views are not supplied. Example : 0 are critical for safety. - Page 61 CDX-S2010/S2010C/S2010T/S2010X/S2050EE 2-2. CD MECHANISM SECTION (1) (MG-611XE-186//Q) not supplied (SENSOR board) not supplied not supplied Ref. No. Part No. Description Remark Ref. No. Part No. Description Remark A-3372-444-A CHASSIS (T) SUB ASSY 2-587-505-01 SCREW 3-253-729-11 SPRING (LTR), TENSION COIL A-1082-775-A SERVO BOARD, COMPLETE...
- Page 62 CDX-S2010/S2010C/S2010T/S2010X/S2050EE 2-3. CD MECHANISM SECTION (2) (MG-611XE-186//Q) (including M901) M902 not supplied not supplied not supplied not supplied Ref. No. Part No. Description Remark Ref. No. Part No. Description Remark A-1075-644-A CHASSIS (OP) COMPLETE ASSY A-3372-446-A LEVER (SL) SUB ASSY 3-316-938-91 SCREW (B1.4X5), TAPPING...
- Page 63 CDX-S2010/S2010C/S2010T/S2010X/S2050EE 2-4. CD MECHANISM SECTION (3) (MG-611XE-186//Q) M903 Ref. No. Part No. Description Remark Ref. No. Part No. Description Remark 3-338-645-31 WASHER (0.8-2.5) 2-186-696-01 BRACKET (LEM-N) 2-186-699-01 GEAR (RA1) 3-345-648-91 SCREW (M1.4), TOOTHED LOCK A-1075-641-B ARM ASSY, ROLLER A-1083-636-A GEAR (LE) ASSY...
- Page 64 CDX-S2010/S2010C/S2010T/S2010X/S2050EE 2-5. CD MECHANISM SECTION (4) (MG-611XE-186//Q) Ref. No. Part No. Description Remark Ref. No. Part No. Description Remark 2-186-700-01 GEAR (CHK1) 2-630-962-01 WASHER (SLIT) 3-344-223-01 WASHER * 256 2-590-545-01 GEAR (LE2-M) 3-259-470-11 GEAR (LE1) A-1075-640-B CHASSIS (M) BLOCK ASSY...
-
Page 65: Electrical Parts List
CDX-S2010/S2010C/S2010T/S2010X/S2050EE SECTION 3 MAIN ELECTRICAL PARTS LIST NOTE: • Due to standardization, replacements in • Items marked “*” are not stocked since The components identified by mark 0 or dotted line with mark the parts list may be different from the they are seldom required for routine service. - Page 66 CDX-S2010/S2010C/S2010T/S2010X/S2050EE MAIN Ref. No. Part No. Description Remark Ref. No. Part No. Description Remark < DIODE > JC12 1-216-864-11 SHORT CHIP JC401 1-216-864-11 SHORT CHIP 8-719-036-94 DIODE RD5.6SB-T1 JC445 1-216-296-11 SHORT CHIP D479 8-719-081-97 DIODE MMDL914T1 JC446 1-216-864-11 SHORT CHIP...
- Page 67 CDX-S2010/S2010C/S2010T/S2010X/S2050EE MAIN Ref. No. Part No. Description Remark Ref. No. Part No. Description Remark R410 1-216-809-11 METAL CHIP 1/10W R544 1-216-821-11 METAL CHIP 1/10W R411 1-216-809-11 METAL CHIP 1/10W R545 1-216-845-11 METAL CHIP 100K 1/10W R431 1-216-809-11 METAL CHIP 1/10W...
- Page 68 CDX-S2010/S2010C/S2010T/S2010X/S2050EE SENSOR SERVO Ref. No. Part No. Description Remark Ref. No. Part No. Description Remark SENSOR BOARD < IC > ************** 6-703-699-01 IC uPD63712GC-8EU-A < SWITCH > 6-705-002-01 IC BA5966FP-FE2 1-529-566-61 SWITCH, PUSH (1 KEY) (SELF) < FERRITE BEAD >...
- Page 69 CDX-S2010/S2010C/S2010T/S2010X/S2050EE Ref. No. Part No. Description Remark MISCELLANEOUS *************** 1-776-206-21 CORD (WITH CONNECTOR) (POWER) (E) 1-776-527-11 CORD (WITH CONNECTOR) (ISO) (POWER) (AEP,UK) 0 153 8-820-207-12 OPTICAL PICK-UP (KSS1000E/K1RP) A-1075-645-A CHASSIS (OP) SUB ASSY (including M901) F901 1-532-877-11 FUSE (BLADE TYPE) (AUTO FUSE) 10A...
- Page 70 CDX-S2010/S2010C/S2010T/S2010X/S2050EE MEMO...
- Page 71 CDX-S2010/S2010C/S2010T/ S2010X/S2050EE US Model Canadian Model SERVICE MANUAL CDX-S2010 AEP Model UK Model Ver. 1.2 2005.06 CDX-S2010T E Model CDX-S2010C/S2010T/S2010X East European Model SUPPLEMENT-2 CDX-S2050EE File this supplement with the service manual. Subject : Change of CD mechanism. This model provides four types of CD mechanisms.
- Page 72 CDX-S2010/S2010C/S2010T/S2010X/S2050EE EXPLODED VIEWS NOTE: • The mechanical parts with no reference • Color Indication of Appearance Parts The components identified by mark 0 or dotted line with mark number in the exploded views are not supplied. Example : 0 are critical for safety.
- Page 73 CDX-S2010/S2010C/S2010T/S2010X/S2050EE 2. CD MECHANISM SECTION (2) (MG-611XE-186K//C) (MG-611XE-186//C) (including M901) M902 not supplied not supplied not supplied The components identified by mark 0 or dotted line with mark 0 are critical for safety. Replace only with part number specified. Ref. No.
- Page 74 CDX-S2010/S2010C/S2010T/S2010X/S2050EE 3. CD MECHANISM SECTION (3) (MG-611XE-186K//C) (MG-611XE-186//C) M903 Ref. No. Part No. Description Remark Ref. No. Part No. Description Remark 3-262-755-11 WASHER (1.1-2.5) 2-186-696-11 BRACKET (LEM-N) (186K//C) 2-186-699-11 GEAR (RA1) (186K//C) 2-186-696-21 BRACKET (LEM-N) (186//C) 2-186-699-21 GEAR (RA1) (186//C) 3-345-648-91 SCREW (M1.4), TOOTHED LOCK...
- Page 75 CDX-S2010/S2010C/S2010T/S2010X/S2050EE 4. CD MECHANISM SECTION (4) (MG-611XE-186K//C) (MG-611XE-186//C) Ref. No. Part No. Description Remark Ref. No. Part No. Description Remark 2-186-700-11 GEAR (CHK1) (186K//C) 3-899-829-01 WASHER (SLIT) 2-186-700-21 GEAR (CHK1) (186//C) 2-590-545-11 GEAR (LE2-M) (186K//C) 3-344-223-01 WASHER 2-590-545-21 GEAR (LE2-M) (186//C)
- Page 76 CDX-S2010/S2010C/S2010T/S2010X/S2050EE REVISION HISTORY Clicking the version allows you to jump to the revised page. Also, clicking the version at the upper on the revised page allows you to jump to the next revised page. Ver. Date Description of Revision 2004.11 Production country change and AEP, UK model addition of 2005.05...