hit counter script
Nokia RM-512 Service Manual
  1. Manuals
  2. Brands
  3. Nokia Manuals
  4. Handhelds
  5. 2330 CLASSIC RM-512
  6. Service manual

Nokia RM-512 Service Manual

Hide thumbs Also See for RM-512:
Table of Contents

Advertisement

Quick Links

Nokia Customer Care
Service Manual
RM-512; RM-513; RM-514; RM-515; RM-543
(Nokia 2330/2320 /2323 Classic)
Mobile Terminal
Part No: 9212952 (Issue 2)
COMPANY CONFIDENTIAL
Copyright © 2009 Nokia. All rights reserved.

Advertisement

Table of Contents
loading

Related Manuals for Nokia RM-512

Summary of Contents for Nokia RM-512

  • Page 1 Nokia Customer Care Service Manual RM-512; RM-513; RM-514; RM-515; RM-543 (Nokia 2330/2320 /2323 Classic) Mobile Terminal Part No: 9212952 (Issue 2) COMPANY CONFIDENTIAL Copyright © 2009 Nokia. All rights reserved.
  • Page 2 Inserted By Comments Issue 1 02/2009 Jeff Zhao Issue 2 02/2009 Jeff Zhao 1. FPS-21 flash prommer added; 2. New information added in "Care and maintenance" section. Page ii COMPANY CONFIDENTIAL Issue 2 Copyright © 2009 Nokia. All rights reserved.
  • Page 3 Nokia operates a policy of continuous development. Nokia reserves the right to make changes and improvements to any of the products described in this document without prior notice. Under no circumstances shall Nokia be responsible for any loss of data or income or any special, incidental, consequential or indirect damages howsoever caused.
  • Page 4 WCDMA networks and cause problems to 3G cellular phone communication in a wide area. • During testing never activate the GSM or WCDMA transmitter without a proper antenna load, otherwise GSM or WCDMA PA may be damaged. Page iv COMPANY CONFIDENTIAL Issue 2 Copyright © 2009 Nokia. All rights reserved.
  • Page 5 Use only approved accessories and batteries. Do not connect incompatible products. CONNECTING TO OTHER DEVICES When connecting to any other device, read its user’s guide for detailed safety instructions. Do not connect incompatible products. Issue 2 COMPANY CONFIDENTIAL Page v Copyright © 2009 Nokia. All rights reserved.
  • Page 6 All of the above suggestions apply equally to the product, battery, charger or any accessory. Due to reduced BOR, phone replacement may be required if parts are unavailable. Page vi COMPANY CONFIDENTIAL Issue 2 Copyright © 2009 Nokia. All rights reserved.
  • Page 7 RM-512; RM-513; RM-514; RM-515; RM-543 ESD protection ESD protection Nokia requires that service points have sufficient ESD protection (against static electricity) when servicing the phone. Any product of which the covers are removed must be handled with ESD protection. The SIM card can be replaced without ESD protection if the product is otherwise ready for use.
  • Page 8 Batteries' performance is particularly limited in temperatures well below freezing. Do not dispose of batteries in a fire! Dispose of batteries according to local regulations (e.g. recycling). Do not dispose as household waste. Page viii COMPANY CONFIDENTIAL Issue 2 Copyright © 2009 Nokia. All rights reserved.
  • Page 9 Our policy is of continuous development; details of all technical modifications will be included with service bulletins. While every endeavour has been made to ensure the accuracy of this document, some errors may exist. If any errors are found by the reader, NOKIA MOBILE PHONES Business Group should be notified in writing/e- mail. Please state: •...
  • Page 10 RM-512; RM-513; RM-514; RM-515; RM-543 Company policy (This page left intentionally blank.) Page x COMPANY CONFIDENTIAL Issue 2 Copyright © 2009 Nokia. All rights reserved.
  • Page 11 RM-512; RM-513; RM-514; RM-515; RM-543 Nokia 2330/2320 /2323 Classic Service Manual Structure Nokia 2330/2320 /2323 Classic Service Manual Structure 1 General Information 2 Service Devices and Service Concepts 3 Baseband Troubleshooting Instructions 4 RF Troubleshooting Instructions 5 Camera Module Troubleshooting...
  • Page 12 RM-512; RM-513; RM-514; RM-515; RM-543 Nokia 2330/2320 /2323 Classic Service Manual Structure (This page left intentionally blank.) Page xii COMPANY CONFIDENTIAL Issue 2 Copyright © 2009 Nokia. All rights reserved.
  • Page 13 Nokia Customer Care 1 — General Information Issue 2 COMPANY CONFIDENTIAL Page 1 –1 Copyright © 2009 Nokia. All rights reserved.
  • Page 14 RM-512; RM-513; RM-514; RM-515; RM-543 General Information (This page left intentionally blank.) Page 1 –2 COMPANY CONFIDENTIAL Issue 2 Copyright © 2009 Nokia. All rights reserved.

  • Page 15: Table Of Contents

    List of Tables Table 1 Power .................................1–7 Table 2 Car................................1–7 Table 3 Audio ................................1–7 List of Figures Figure 1 RM-512/RM-513 product picture......................1–5 Figure 2 RM-514/RM-515/RM-543 product picture .....................1–6 Issue 2 COMPANY CONFIDENTIAL Page 1 –3 Copyright © 2009 Nokia. All rights reserved.
  • Page 16 RM-512; RM-513; RM-514; RM-515; RM-543 General Information (This page left intentionally blank.) Page 1 –4 COMPANY CONFIDENTIAL Issue 2 Copyright © 2009 Nokia. All rights reserved.

  • Page 17: Rm-512/Rm-513/Rm-514/Rm-515/Rm-543 Product Selection

    General Information RM-512/RM-513/RM-514/RM-515/RM-543 product selection The RM-512, RM-514 and RM-543 are the EU versions of the telephone with a dual band transceiver unit designed for the GSM900 and GSM1800 networks. The RM-513 and RM-515 are the US versions of the telephone with a dual band transceiver unit designed for the GSM850 and GSM1900 networks.

  • Page 18: Features

    • IHF Slim Malt 16mm Speaker • Internal antenna • Easy flash II system connector • BT combined with FM radio (only RM-512/513/543) • 0.3 MPix camera (only RM-512/513) • Built-in Vibra • GPRS: Class 6 Software features • OS: ISA •...

  • Page 19: Ui Features

    NOKIA extra power DC-4 Mobile charger Table 2 Car Type Name CR-39 NOKIA universal holder Table 3 Audio Type Name WH-101 Stereo headset BH-102 Bluetooth headset Issue 2 COMPANY CONFIDENTIAL Page 1 –7 Copyright © 2009 Nokia. All rights reserved.
  • Page 20 RM-512; RM-513; RM-514; RM-515; RM-543 General Information Type Name HH-17 NOKIA car kit HF-200 Car handsfree Page 1 –8 COMPANY CONFIDENTIAL Issue 2 Copyright © 2009 Nokia. All rights reserved.
  • Page 21 Nokia Customer Care 2 — Service Devices and Service Concepts Issue 2 COMPANY CONFIDENTIAL Page 2 –1 Copyright © 2009 Nokia. All rights reserved.
  • Page 22 RM-512; RM-513; RM-514; RM-515; RM-543 Service Devices and Service Concepts (This page left intentionally blank.) Page 2 –2 COMPANY CONFIDENTIAL Issue 2 Copyright © 2009 Nokia. All rights reserved.

  • Page 23: Table Of Contents

    Figure 7 RF-test/BB-tune concept with JBV-1 ....................2–19 Figure 8 EM calibration concept with JBV-1...................... 2–20 Figure 9 RF-test/BB-tune & flash concept with JBV-1, FPS-10................. 2–21 Issue 2 COMPANY CONFIDENTIAL Page 2 –3 Copyright © 2009 Nokia. All rights reserved.
  • Page 24 Figure 10 RF-test/BB-tune & flash concept with JBV-1, FPS-21............... 2–22 Figure 11 RF/BB tune & flash concept with MJ-219, FPS-10 ................2–23 Figure 12 RF/BB tune& flash concept with MJ-xxx, FPS-21................2–24 Page 2 –4 COMPANY CONFIDENTIAL Issue 2 Copyright © 2009 Nokia. All rights reserved.

  • Page 25: Service Devices

    The table below gives a short overview of service devices that can be used for testing, error analysis, and repair of product RM-512; RM-513; RM-514; RM-515; RM-543. For the correct use of the service devices, and the best effort of workbench setup, please refer to various concepts.
  • Page 26 Features include: • compatible with JBV-1 • easy phone attachment and detachment • reliable phone locking • switch for detecting phone • replaceable SIM interface Page 2 –6 COMPANY CONFIDENTIAL Issue 2 Copyright © 2009 Nokia. All rights reserved.

  • Page 27: Dau-9S

    FLS-5 is a dongle and flash device incorporated into one package, developed specifically for POS use. Note: FLS-5 can be used as an alternative to PKD-1. Issue 2 COMPANY CONFIDENTIAL Page 2 –7 Copyright © 2009 Nokia. All rights reserved.
  • Page 28 FPS-10 sales package includes: • FPS-10 prommer • Power Supply with 5 country specific cords • USB cable Note: FPS-21 is substitute FPS-10 if FPS-10 has not been set Page 2 –8 COMPANY CONFIDENTIAL Issue 2 Copyright © 2009 Nokia. All rights reserved.
  • Page 29 FPS-21, the prommer needs to be opened by removing the front panel, rear panel and heatsink from the prommer body. Note: FPS-10 can be used for flashing instead of FPS-21 if necessary. Issue 2 COMPANY CONFIDENTIAL Page 2 –9 Copyright © 2009 Nokia. All rights reserved.
  • Page 30 • BTEMP and BSI calibration resistor • signal from FBUS to the phone via the parallel jig • control via FBUS or USB • Flash OK/FAIL indication Page 2 –10 COMPANY CONFIDENTIAL Issue 2 Copyright © 2009 Nokia. All rights reserved.
  • Page 31 PCS-1 Power cable The PCS-1 power cable (DC) is used with a docking station, a module jig or a control unit to supply a controlled voltage. Issue 2 COMPANY CONFIDENTIAL Page 2 –11 Copyright © 2009 Nokia. All rights reserved.
  • Page 32 RJ-230 is a soldering jig used for soldering and as a rework jig for the engine module. RJ-51 Rework jig To be used with ST-30! RJ-72 Rework jig To be used with rework stencil ST-28. Page 2 –12 COMPANY CONFIDENTIAL Issue 2 Copyright © 2009 Nokia. All rights reserved.
  • Page 33 The peeling tool SS-108 is used to peel off the shielding. SS-93 Opening tool SS-93 is used for opening JAE connectors. Note: The SS-93 is included in Nokia Standard Toolkit. Issue 2 COMPANY CONFIDENTIAL Page 2 –13 Copyright © 2009 Nokia. All rights reserved.
  • Page 34 The RF cable is used to connect, for example, a module repair jig to the RF measurement equipment. SMA to N-Connector approximately 610 mm. Attenuation for: • GSM850/900: 0.3+-0.1 dB • GSM1800/1900: 0.5+-0.1 dB • WLAN: 0.6+-0.1dB Page 2 –14 COMPANY CONFIDENTIAL Issue 2 Copyright © 2009 Nokia. All rights reserved.

  • Page 35: Service Concepts

    RM-512; RM-513; RM-514; RM-515; RM-543 Service Devices and Service Concepts Service concepts POS flash concept with FLS-4S Figure 3 POS flash concept with FLS-4S Issue 2 COMPANY CONFIDENTIAL Page 2 –15 Copyright © 2009 Nokia. All rights reserved.

  • Page 36: Pos Flash Concept With Fls-5

    RM-512; RM-513; RM-514; RM-515; RM-543 Service Devices and Service Concepts POS flash concept with FLS-5 Figure 4 POS flash concept with FLS-5 Page 2 –16 COMPANY CONFIDENTIAL Issue 2 Copyright © 2009 Nokia. All rights reserved.

  • Page 37: Flash Concept With Fps-10

    RM-512; RM-513; RM-514; RM-515; RM-543 Service Devices and Service Concepts Flash concept with FPS-10 Figure 5 Flash concept with FPS-10 Issue 2 COMPANY CONFIDENTIAL Page 2 –17 Copyright © 2009 Nokia. All rights reserved.

  • Page 38: Flash Concept With Fps-21

    RM-512; RM-513; RM-514; RM-515; RM-543 Service Devices and Service Concepts Flash concept with FPS-21 Figure 6 Flash concept with FPS-21 Page 2 –18 COMPANY CONFIDENTIAL Issue 2 Copyright © 2009 Nokia. All rights reserved.

  • Page 39: Rf-Test/Bb-Tune Concept With Jbv-1

    RM-512; RM-513; RM-514; RM-515; RM-543 Service Devices and Service Concepts RF-test/BB-tune concept with JBV-1 Figure 7 RF-test/BB-tune concept with JBV-1 Issue 2 COMPANY CONFIDENTIAL Page 2 –19 Copyright © 2009 Nokia. All rights reserved.

  • Page 40: Em Calibration Concept With Jbv-1

    RM-512; RM-513; RM-514; RM-515; RM-543 Service Devices and Service Concepts EM calibration concept with JBV-1 Figure 8 EM calibration concept with JBV-1 Page 2 –20 COMPANY CONFIDENTIAL Issue 2 Copyright © 2009 Nokia. All rights reserved.

  • Page 41: Rf-Test/Bb-Tune & Flash Concept With Jbv-1, Fps-10

    RM-512; RM-513; RM-514; RM-515; RM-543 Service Devices and Service Concepts RF-test/BB-tune & flash concept with JBV-1, FPS-10 Figure 9 RF-test/BB-tune & flash concept with JBV-1, FPS-10 Issue 2 COMPANY CONFIDENTIAL Page 2 –21 Copyright © 2009 Nokia. All rights reserved.

  • Page 42: Rf-Test/Bb-Tune & Flash Concept With

    RM-512; RM-513; RM-514; RM-515; RM-543 Service Devices and Service Concepts RF-test/BB-tune & flash concept with JBV-1, FPS-21 Figure 10 RF-test/BB-tune & flash concept with JBV-1, FPS-21 Page 2 –22 COMPANY CONFIDENTIAL Issue 2 Copyright © 2009 Nokia. All rights reserved.

  • Page 43: Rf/Bb Tune & Flash Concept With Mj-219, Fps-10

    RM-512; RM-513; RM-514; RM-515; RM-543 Service Devices and Service Concepts RF/BB tune & flash concept with MJ-219, FPS-10 Figure 11 RF/BB tune & flash concept with MJ-219, FPS-10 Issue 2 COMPANY CONFIDENTIAL Page 2 –23 Copyright © 2009 Nokia. All rights reserved.

  • Page 44: Rf/Bb Tune& Flash Concept With Mj-Xxx, Fps-21

    RM-512; RM-513; RM-514; RM-515; RM-543 Service Devices and Service Concepts RF/BB tune& flash concept with MJ-xxx, FPS-21 Figure 12 RF/BB tune& flash concept with MJ-xxx, FPS-21 Page 2 –24 COMPANY CONFIDENTIAL Issue 2 Copyright © 2009 Nokia. All rights reserved.
  • Page 45 Nokia Customer Care 3 — Baseband Troubleshooting Instructions Issue 2 COMPANY CONFIDENTIAL Page 3 –1 Copyright © 2009 Nokia. All rights reserved.
  • Page 46 RM-512; RM-513; RM-514; RM-515; RM-543 Baseband Troubleshooting Instructions (This page left intentionally blank.) Page 3 –2 COMPANY CONFIDENTIAL Issue 2 Copyright © 2009 Nokia. All rights reserved.

  • Page 47: Table 3 Audio

    Figure 25 Test arrangement for of earpiece..................... 3–19 Figure 26 Checking IHF and ring tone by using "Buzzer"................3–20 Figure 27 Checking vibra function by using vibra control ................3–20 Issue 2 COMPANY CONFIDENTIAL Page 3 –3 Copyright © 2009 Nokia. All rights reserved.
  • Page 48 3–22 Figure 30 Microphone fault flow chart......................3–23 Figure 31 Headset earpiece fault flow chart ....................3–24 Figure 32 Headset microphone fault flow chart ....................3–25 Page 3 –4 COMPANY CONFIDENTIAL Issue 2 Copyright © 2009 Nokia. All rights reserved.

  • Page 49: General Baseband Troubleshooting

    RM-512; RM-513; RM-514; RM-515; RM-543 Baseband Troubleshooting Instructions General baseband troubleshooting Key components Power supply test points Issue 2 COMPANY CONFIDENTIAL Page 3 –5 Copyright © 2009 Nokia. All rights reserved.

  • Page 50: Phone Cannot Be Powered On (I)

    It is assumed that the voltage supplied is 3.6VDC. The Liteplus will prevent any functionality at battery/supply levels below 2.9VDC. Troubleshooting flow Figure 13 Troubleshooting when phone cannot be powered on Page 3 –6 COMPANY CONFIDENTIAL Issue 2 Copyright © 2009 Nokia. All rights reserved.

  • Page 51: Phone Cannot Be Powered On (Ii)

    32 seconds. Unfortunately, the service routine can not be measured. Troubleshooting flow Figure 14 Troubleshooting when phone does not stay on or phone is jammed Issue 2 COMPANY CONFIDENTIAL Page 3 –7 Copyright © 2009 Nokia. All rights reserved.

  • Page 52: Phone Cannot Be Flashed

    Because of the use of uBGA components, it is not possible to verify if there is a short circuit in the control and address lines of MCU (UPP8M) and the memory (flash). Page 3 –8 COMPANY CONFIDENTIAL Issue 2 Copyright © 2009 Nokia. All rights reserved.
  • Page 53 RM-512; RM-513; RM-514; RM-515; RM-543 Baseband Troubleshooting Instructions Troubleshooting flow Figure 15 Flash programming fault Issue 2 COMPANY CONFIDENTIAL Page 3 –9 Copyright © 2009 Nokia. All rights reserved.

  • Page 54: Easy Flash Programming Does Not Work

    They are individual test cases, so the below lineup of error hunting's has no chronological order. Use common sense and experience to decide which test case to start error hunting at. Page 3 –10 COMPANY CONFIDENTIAL Issue 2 Copyright © 2009 Nokia. All rights reserved.

  • Page 55: The Phone Does Not Register To The Networks, Or The Phone Cannot Make A Call

    'buried' in one or more of the inner layers of the PWB. First, check that SIM LOCK is not causing the error by using a Test-SIM card and connect the phone to a tester. Issue 2 COMPANY CONFIDENTIAL Page 3 –11 Copyright © 2009 Nokia. All rights reserved.

  • Page 56: Sim Related Faults

    SIM card. When the power is switched on the phone first check for a 1.8V SIM card and then a 3V SIM card. The phone will try this four times, where after it will display ”Insert SIM card”. Page 3 –12 COMPANY CONFIDENTIAL Issue 2 Copyright © 2009 Nokia. All rights reserved.

  • Page 57: Sim Card Rejected

    The first data is always ATR and it is sent from card to phone. For reference a picture with normal SIM power-up is shown below. Issue 2 COMPANY CONFIDENTIAL Page 3 –13 Copyright © 2009 Nokia. All rights reserved.

  • Page 58: User Interface

    The display does not show any information at all. For display blank, refer to troubleshooting flow below. Troubleshooting flow Corrupted display Context The display contains missing or fading segments, or color presentation is incorrect. Page 3 –14 COMPANY CONFIDENTIAL Issue 2 Copyright © 2009 Nokia. All rights reserved.

  • Page 59: Dead Keys

    No backlight for display or/and keys Context There are 3 kinds of statuses: No backlight for both display and keys; No backlight for only display; No backlight for only keys. Issue 2 COMPANY CONFIDENTIAL Page 3 –15 Copyright © 2009 Nokia. All rights reserved.
  • Page 60 RM-512; RM-513; RM-514; RM-515; RM-543 Baseband Troubleshooting Instructions Troubleshooting flow Page 3 –16 COMPANY CONFIDENTIAL Issue 2 Copyright © 2009 Nokia. All rights reserved.

  • Page 61: Audio Troubleshooting

    RM-512; RM-513; RM-514; RM-515; RM-543 Baseband Troubleshooting Instructions Audio troubleshooting Audio troubleshooting using phoenix Figure 22 Phoenix audio test window Issue 2 COMPANY CONFIDENTIAL Page 3 –17 Copyright © 2009 Nokia. All rights reserved.

  • Page 62: Check Microphone Using "Hp Microphone In Ext Speaker Out" Loop

    3. Select “Hp microphone in Ext speaker out” 4. Select "Acc. Detection" as "Off". 5. Select “Loop” as “On” 6. Input sound at microphone port, for example 94dB SPL 1kHz. Page 3 –18 COMPANY CONFIDENTIAL Issue 2 Copyright © 2009 Nokia. All rights reserved.

  • Page 63: Check Earpiece Using "Ext Microphone In Hp Speaker Out" Loop

    2. Open “audio test” window from “Testing -> Audio test”, as shown in above. 3. In “Buzzer” area, select suitable signal to be played, for example 1 kHz, Strength 5” 4. Select “Volume” as “On” Issue 2 COMPANY CONFIDENTIAL Page 3 –19 Copyright © 2009 Nokia. All rights reserved.

  • Page 64: Check Vibra Function Using "Vibra Control

    3. Select suitable intensity value, for example 53 %. 4. Select “Vibra state” as “Enabled” 5. Click “Write”. 6. Check if Vibra works. Figure 27 Checking vibra function by using vibra control Page 3 –20 COMPANY CONFIDENTIAL Issue 2 Copyright © 2009 Nokia. All rights reserved.

  • Page 65: Earpiece Fault

    RM-512; RM-513; RM-514; RM-515; RM-543 Baseband Troubleshooting Instructions Earpiece fault Troubleshooting flow Figure 28 Earpiece fault flow chart Issue 2 COMPANY CONFIDENTIAL Page 3 –21 Copyright © 2009 Nokia. All rights reserved.

  • Page 66: Ihf/Ringing Tone Fault

    RM-512; RM-513; RM-514; RM-515; RM-543 Baseband Troubleshooting Instructions IHF/ringing tone fault Troubleshooting flow Figure 29 IHF/ringing tone fault flow chart Page 3 –22 COMPANY CONFIDENTIAL Issue 2 Copyright © 2009 Nokia. All rights reserved.

  • Page 67: Microphone Fault

    RM-512; RM-513; RM-514; RM-515; RM-543 Baseband Troubleshooting Instructions Microphone fault Troubleshooting flow Figure 30 Microphone fault flow chart Issue 2 COMPANY CONFIDENTIAL Page 3 –23 Copyright © 2009 Nokia. All rights reserved.

  • Page 68: Headset Earpiece Fault

    RM-512; RM-513; RM-514; RM-515; RM-543 Baseband Troubleshooting Instructions Headset earpiece fault Troubleshooting flow Figure 31 Headset earpiece fault flow chart Page 3 –24 COMPANY CONFIDENTIAL Issue 2 Copyright © 2009 Nokia. All rights reserved.

  • Page 69: Headset Microphone Fault

    RM-512; RM-513; RM-514; RM-515; RM-543 Baseband Troubleshooting Instructions Headset microphone fault Troubleshooting flow Figure 32 Headset microphone fault flow chart Issue 2 COMPANY CONFIDENTIAL Page 3 –25 Copyright © 2009 Nokia. All rights reserved.
  • Page 70 RM-512; RM-513; RM-514; RM-515; RM-543 Baseband Troubleshooting Instructions (This page left intentionally blank.) Page 3 –26 COMPANY CONFIDENTIAL Issue 2 Copyright © 2009 Nokia. All rights reserved.
  • Page 71 Nokia Customer Care 4 — RF Troubleshooting Instructions Issue 2 COMPANY CONFIDENTIAL Page 4 –1 Copyright © 2009 Nokia. All rights reserved.
  • Page 72 RM-512; RM-513; RM-514; RM-515; RM-543 RF Troubleshooting Instructions (This page left intentionally blank.) Page 4 –2 COMPANY CONFIDENTIAL Issue 2 Copyright © 2009 Nokia. All rights reserved.
  • Page 73 List of Figures Figure 33 RF key components on PWB.........................4–7 Figure 34 Supply points at UEM (D2200) ......................4–8 Figure 35 Supply point at RF IC (N7600) ......................4–9 Issue 2 COMPANY CONFIDENTIAL Page 4 –3 Copyright © 2009 Nokia. All rights reserved.
  • Page 74 4–47 Figure 84 PLL Troubleshooting diagram......................4–48 Figure 85 Measurement points for VCXO......................4–49 Figure 86 Phoenix settings..........................4–50 Figure 87 FM circuit troubleshooting diagram....................4–51 Page 4 –4 COMPANY CONFIDENTIAL Issue 2 Copyright © 2009 Nokia. All rights reserved.
  • Page 75 Figure 90 FM module output signal........................4–52 Figure 91 BER test result............................. 4–54 Figure 92 Bluetooth self tests in Phoenix ......................4–55 Figure 93 Antenna troubleshooting ........................4–57 Issue 2 COMPANY CONFIDENTIAL Page 4 –5 Copyright © 2009 Nokia. All rights reserved.
  • Page 76 RM-512; RM-513; RM-514; RM-515; RM-543 RF Troubleshooting Instructions (This page left intentionally blank.) Page 4 –6 COMPANY CONFIDENTIAL Issue 2 Copyright © 2009 Nokia. All rights reserved.

  • Page 77: General Rf Troubleshooting

    RF key components Figure 33 RF key components on PWB N7600 PMB3258 RF IC N7700 FEM (PA and antenna switch) Z7602 EGSM 850/900 RX SAW filter Issue 2 COMPANY CONFIDENTIAL Page 4 –7 Copyright © 2009 Nokia. All rights reserved.
  • Page 78 BT & FM IC Z6000 BT SAW filter Refer to the picture below for measuring points at the UEM (D2200). Figure 34 Supply points at UEM (D2200) Page 4 –8 COMPANY CONFIDENTIAL Issue 2 Copyright © 2009 Nokia. All rights reserved.

  • Page 79: Auto Tuning

    Autotune is designed to align the phone's RF part easier and faster. It performs calibrations, tunings and measurements of RX and TX. The results are displayed and logged in a result file, if initiated. Hardware set up Hardware requirements for auto tuning: Issue 2 COMPANY CONFIDENTIAL Page 4 –9 Copyright © 2009 Nokia. All rights reserved.

  • Page 80: Rm-512/514/543 Receiver

    Band: GSM 900 iii Operation Mode: Continuous mode iv RX/TX Channel 37 AGC: 8: FEG_ON + DTOS_ON+BB_6=Vgain_36 Results The setup should now look like this: Page 4 –10 COMPANY CONFIDENTIAL Issue 2 Copyright © 2009 Nokia. All rights reserved.
  • Page 81 RM-512; RM-513; RM-514; RM-515; RM-543 RF Troubleshooting Instructions Figure 37 GSM900 RF controls window Issue 2 COMPANY CONFIDENTIAL Page 4 –11 Copyright © 2009 Nokia. All rights reserved.

  • Page 82: Troubleshooting Diagram For Gsm900 Receiver

    By measuring with an oscilloscope at RXIP or RXQP on a working GSM900 receiver this picture should be seen. Signal amplitude peak-peak 108mV. DC offset 1.0V. Page 4 –12 COMPANY CONFIDENTIAL Issue 2 Copyright © 2009 Nokia. All rights reserved.

  • Page 83: General Instructions For Gsm 1800 Rx Troubleshooting

    Band: GSM 1800 iii Operation Mode: Continuous mode iv RX/TX Channel 700 AGC: 8: FEG_ON + DTOS_ON+BB_6=Vgain_36 Results The setup should now look like this: Issue 2 COMPANY CONFIDENTIAL Page 4 –13 Copyright © 2009 Nokia. All rights reserved.
  • Page 84 RM-512; RM-513; RM-514; RM-515; RM-543 RF Troubleshooting Instructions Figure 40 GSM1800 RF controls window Page 4 –14 COMPANY CONFIDENTIAL Issue 2 Copyright © 2009 Nokia. All rights reserved.

  • Page 85: Troubleshooting Diagram For Gsm1800 Receiver

    By measuring with an oscilloscope at RXIP or RXQP on a working GSM1800 receiver this picture should be seen. Signal amplitude peak-peak 114mV. DC offset 1.0V. Issue 2 COMPANY CONFIDENTIAL Page 4 –15 Copyright © 2009 Nokia. All rights reserved.

  • Page 86: Measurement Points In The Receiver

    RF Troubleshooting Instructions Figure 42 1800 RX I/Q signal waveform Measurement points in the receiver Figure 43 RX measurements point of the control voltages to FEM N7700 Page 4 –16 COMPANY CONFIDENTIAL Issue 2 Copyright © 2009 Nokia. All rights reserved.
  • Page 87 RM-512; RM-513; RM-514; RM-515; RM-543 RF Troubleshooting Instructions Figure 44 Measurement points at the RX SAW Filters – Z7600/Z7602 Figure 45 RX I/Q signals Issue 2 COMPANY CONFIDENTIAL Page 4 –17 Copyright © 2009 Nokia. All rights reserved.

  • Page 88: Rm-512/514/543 Transmitter

    6. Set the parameters as follows: Band: GSM 900 ii Active Unit: TX iii TX Power Level: 5 iv TX Data Type: Random Results The setup should now look like this: Page 4 –18 COMPANY CONFIDENTIAL Issue 2 Copyright © 2009 Nokia. All rights reserved.
  • Page 89 RM-512; RM-513; RM-514; RM-515; RM-543 RF Troubleshooting Instructions Figure 46 GSM 900 RF controls window Issue 2 COMPANY CONFIDENTIAL Page 4 –19 Copyright © 2009 Nokia. All rights reserved.

  • Page 90: Troubleshooting Diagram For Gsm900 Transmitter

    Figure 47 GSM900 tarnsmitter troubleshooting GSM900 TX output power Measure the output power of the phone; it should be about 32.5dBm. Remember the cable loss is about 0.3dB. Page 4 –20 COMPANY CONFIDENTIAL Issue 2 Copyright © 2009 Nokia. All rights reserved.
  • Page 91 RM-512; RM-513; RM-514; RM-515; RM-543 RF Troubleshooting Instructions Figure 48 TX I/O signal Figure 49 VC1, VC3 signals Issue 2 COMPANY CONFIDENTIAL Page 4 –21 Copyright © 2009 Nokia. All rights reserved.
  • Page 92 RM-512; RM-513; RM-514; RM-515; RM-543 RF Troubleshooting Instructions Figure 50 TXP signal Figure 51 TXC signals at PCL5 Page 4 –22 COMPANY CONFIDENTIAL Issue 2 Copyright © 2009 Nokia. All rights reserved.

  • Page 93: General Instructions For Gsm1800 Tx Troubleshooting

    6. Set the parameters as follows: Band: GSM 1800 ii Active Unit: TX iii TX Power Level: 0 iv TX Data Type: Random Results The setup should now look like this: Issue 2 COMPANY CONFIDENTIAL Page 4 –23 Copyright © 2009 Nokia. All rights reserved.
  • Page 94 RM-512; RM-513; RM-514; RM-515; RM-543 RF Troubleshooting Instructions Figure 53 GSM 1800 RF controls window Page 4 –24 COMPANY CONFIDENTIAL Issue 2 Copyright © 2009 Nokia. All rights reserved.

  • Page 95: Troubleshooting Diagram For Gsm1800 Transmitter

    Figure 54 GSM1800 transmitter troubleshooting GSM1800 TX output power Measure the output power of the phone; it should be about 30.5dBm. Remember the cable loss is about 0.5dB. Issue 2 COMPANY CONFIDENTIAL Page 4 –25 Copyright © 2009 Nokia. All rights reserved.
  • Page 96 RM-512; RM-513; RM-514; RM-515; RM-543 RF Troubleshooting Instructions Figure 55 TX I/O signal Figure 56 VC1, VC2, VC3 signals Page 4 –26 COMPANY CONFIDENTIAL Issue 2 Copyright © 2009 Nokia. All rights reserved.
  • Page 97 RM-512; RM-513; RM-514; RM-515; RM-543 RF Troubleshooting Instructions Figure 57 TXP signal Figure 58 TXC signals at PCL0 Issue 2 COMPANY CONFIDENTIAL Page 4 –27 Copyright © 2009 Nokia. All rights reserved.

  • Page 98: Rm-513/515 Receiver

    Band: GSM 850 iii Operation Mode: Continuous mode iv RX/TX Channel 190 AGC: 8: FEG_ON + DTOS_ON+BB_6=Vgain_36 Results The setup should now look like this: Page 4 –28 COMPANY CONFIDENTIAL Issue 2 Copyright © 2009 Nokia. All rights reserved.
  • Page 99 RM-512; RM-513; RM-514; RM-515; RM-543 RF Troubleshooting Instructions Figure 60 GSM850 RF controls window Issue 2 COMPANY CONFIDENTIAL Page 4 –29 Copyright © 2009 Nokia. All rights reserved.

  • Page 100: Troubleshooting Diagram For Gsm850 Receiver

    RM-512; RM-513; RM-514; RM-515; RM-543 RF Troubleshooting Instructions Troubleshooting diagram for GSM850 receiver Troubleshooting flow Figure 61 GSM850 receiver troubleshooting Page 4 –30 COMPANY CONFIDENTIAL Issue 2 Copyright © 2009 Nokia. All rights reserved.

  • Page 101: General Instructions For Gsm1900 Rx Troubleshooting

    Band: GSM 1900 iii Operation Mode: Continuous mode iv RX/TX Channel 661 AGC: 8: FEG_ON + DTOS_ON+BB_6=Vgain_36 Results The setup should now look like this: Issue 2 COMPANY CONFIDENTIAL Page 4 –31 Copyright © 2009 Nokia. All rights reserved.
  • Page 102 RM-512; RM-513; RM-514; RM-515; RM-543 RF Troubleshooting Instructions Figure 63 GSM 1900 RF controls window Page 4 –32 COMPANY CONFIDENTIAL Issue 2 Copyright © 2009 Nokia. All rights reserved.

  • Page 103: Troubleshooting Diagram For Gsm1900 Receiver

    RM-512; RM-513; RM-514; RM-515; RM-543 RF Troubleshooting Instructions Troubleshooting diagram for GSM1900 receiver Troubleshooting flow Figure 64 GSM1900 receiver troubleshooting Issue 2 COMPANY CONFIDENTIAL Page 4 –33 Copyright © 2009 Nokia. All rights reserved.

  • Page 104: Measurement Points In The Receiver

    Signal amplitude 108 mVp-p. DC offset 1.0V. Figure 65 1900 RX I/Q signal waveform Measurement points in the receiver Figure 66 RX measurements point of the control voltages to FEM N7700 Page 4 –34 COMPANY CONFIDENTIAL Issue 2 Copyright © 2009 Nokia. All rights reserved.
  • Page 105 RM-512; RM-513; RM-514; RM-515; RM-543 RF Troubleshooting Instructions Figure 67 Measurement points at the RX SAW Filters – Z7600/Z7602 Figure 68 RX I/Q signals Issue 2 COMPANY CONFIDENTIAL Page 4 –35 Copyright © 2009 Nokia. All rights reserved.

  • Page 106: Rm-513/515 Transmitter

    6. Set the parameters as follows: Band: GSM 850 ii Active Unit: TX iii TX Power Level: 5 iv TX Data Type: Random Results The setup should now look like this: Page 4 –36 COMPANY CONFIDENTIAL Issue 2 Copyright © 2009 Nokia. All rights reserved.
  • Page 107 RM-512; RM-513; RM-514; RM-515; RM-543 RF Troubleshooting Instructions Figure 69 GSM 850 RF controls window Issue 2 COMPANY CONFIDENTIAL Page 4 –37 Copyright © 2009 Nokia. All rights reserved.

  • Page 108: Troubleshooting Diagram For Gsm850 Transmitter

    RM-512; RM-513; RM-514; RM-515; RM-543 RF Troubleshooting Instructions Troubleshooting diagram for GSM850 transmitter Troubleshooting flow Figure 70 GSM850 transmitter troubleshooting Page 4 –38 COMPANY CONFIDENTIAL Issue 2 Copyright © 2009 Nokia. All rights reserved.

  • Page 109: Gsm850 Tx Output Power

    Measure the output power of the phone; it should be about 32.5 dBm. Remember the cable loss is about 0.3 Figure 71 TX I/O signal Figure 72 VC1, VC3 signal Issue 2 COMPANY CONFIDENTIAL Page 4 –39 Copyright © 2009 Nokia. All rights reserved.
  • Page 110 RM-512; RM-513; RM-514; RM-515; RM-543 RF Troubleshooting Instructions Figure 73 TXP signal Figure 74 TXC signals at PCL5 Page 4 –40 COMPANY CONFIDENTIAL Issue 2 Copyright © 2009 Nokia. All rights reserved.

  • Page 111: General Instructions For Gsm1900 Tx Troubleshooting

    5. Select Testing and RF Controls. 6. Set the parameters as follows: Band: GSM 1900 ii Active Unit: TX iii TX Power Level: 0 iv TX Data Type: Random Issue 2 COMPANY CONFIDENTIAL Page 4 –41 Copyright © 2009 Nokia. All rights reserved.
  • Page 112 RM-512; RM-513; RM-514; RM-515; RM-543 RF Troubleshooting Instructions 7. The setup should now look like this: Figure 76 GSM 1900 RF controls window Page 4 –42 COMPANY CONFIDENTIAL Issue 2 Copyright © 2009 Nokia. All rights reserved.

  • Page 113: Troubleshooting Diagram For Gsm1900 Transmitter

    RM-512; RM-513; RM-514; RM-515; RM-543 RF Troubleshooting Instructions Troubleshooting diagram for GSM1900 transmitter Troubleshooting flow Figure 77 GSM1900 transmitter troubleshooting Issue 2 COMPANY CONFIDENTIAL Page 4 –43 Copyright © 2009 Nokia. All rights reserved.

  • Page 114: Gsm1900 Tx Output Power

    Measure the output power of the phone; it should be about 29.1dBm. Remember the cable loss is about 0.5dB. Figure 78 TX I/O signal Figure 79 VC1, VC2, VC3 signals Page 4 –44 COMPANY CONFIDENTIAL Issue 2 Copyright © 2009 Nokia. All rights reserved.
  • Page 115 RM-512; RM-513; RM-514; RM-515; RM-543 RF Troubleshooting Instructions Figure 80 TXP signal Figure 81 TXC signals at PCL0 Issue 2 COMPANY CONFIDENTIAL Page 4 –45 Copyright © 2009 Nokia. All rights reserved.

  • Page 116: Synthesizer Troubleshooting

    The 26MHz signal from the VCXO can be measured by probing R2900. The level at this point is approx. 770mVpp. Frequency of this oscillator is adjusted by changing the AFC-register inside the UEM IC. Example Signal Measured at VCXO output (R2900). Page 4 –46 COMPANY CONFIDENTIAL Issue 2 Copyright © 2009 Nokia. All rights reserved.
  • Page 117 RM-512; RM-513; RM-514; RM-515; RM-543 RF Troubleshooting Instructions Figure 83 VCXO 26 MHz waveform Issue 2 COMPANY CONFIDENTIAL Page 4 –47 Copyright © 2009 Nokia. All rights reserved.

  • Page 118: Troubleshooting Diagram For Pll Synthesizer

    RM-512; RM-513; RM-514; RM-515; RM-543 RF Troubleshooting Instructions Troubleshooting diagram for PLL synthesizer Figure 84 PLL Troubleshooting diagram Page 4 –48 COMPANY CONFIDENTIAL Issue 2 Copyright © 2009 Nokia. All rights reserved.

  • Page 119: Measurement Points At The Vcxo

    1. Connect the phone to a PC with the module repair jig. 2. Start Phoenix and establish a connection to the phone with the data cable e.g. FBUS. 3. Phoenix settings shall be as follows: Issue 2 COMPANY CONFIDENTIAL Page 4 –49 Copyright © 2009 Nokia. All rights reserved.
  • Page 120 5. Signal generator settings shall be as follows: Frequency: 98 MHz ii Level: - 60 dBm iii FM deviation: 75 kHz iv LFGEN frequency: 1 kHZ Page 4 –50 COMPANY CONFIDENTIAL Issue 2 Copyright © 2009 Nokia. All rights reserved.

  • Page 121: Troubleshooting Diagram For Fm Radio

    RM-512; RM-513; RM-514; RM-515; RM-543 RF Troubleshooting Instructions Troubleshooting diagram for FM radio Troubleshooting flow Figure 87 FM circuit troubleshooting diagram Issue 2 COMPANY CONFIDENTIAL Page 4 –51 Copyright © 2009 Nokia. All rights reserved.

  • Page 122: Bluetooth And Fm Radio Test Points

    RF Troubleshooting Instructions Bluetooth and FM radio test points Figure 88 Bluetooth and FM radio test points Figure 89 XAUDIO output signal Figure 90 FM module output signal Page 4 –52 COMPANY CONFIDENTIAL Issue 2 Copyright © 2009 Nokia. All rights reserved.

  • Page 123: Introduction To Bluetooth Troubleshooting

    7. Place the JBT-9 box near (within 10 cm) the BT antenna and click Run BER Test. Results Bit Error Rate (BER) Tests pane in the Bluetooth LOCALS window. Bit Error Rate test result is displayed in the Issue 2 COMPANY CONFIDENTIAL Page 4 –53 Copyright © 2009 Nokia. All rights reserved.

  • Page 124: Bluetooth Self Tests In Phoenix

    4. From the Mode drop-down menu, set mode to Local. 5. Choose Testing→Self Tests. Self Tests window check the following Bluetooth related tests: 6. In the • ST_LPRF_IF_TEST • ST_LPRF_AUDIO_LINES_TEST • ST_BT_WAKEUP_TEST Page 4 –54 COMPANY CONFIDENTIAL Issue 2 Copyright © 2009 Nokia. All rights reserved.

  • Page 125: Bluetooth Ber Failure Troubleshooting

    Bluetooth BER failure troubleshooting Context Basic encoding rules, BER, is a self-identifying and self-delimiting encoding scheme, which means that each data value can be identified, extracted and decoded individually. Issue 2 COMPANY CONFIDENTIAL Page 4 –55 Copyright © 2009 Nokia. All rights reserved.
  • Page 126 RM-512; RM-513; RM-514; RM-515; RM-543 RF Troubleshooting Instructions Bluetooth circuit troubleshooting diagram Page 4 –56 COMPANY CONFIDENTIAL Issue 2 Copyright © 2009 Nokia. All rights reserved.

  • Page 127: Antenna Troubleshooting

    RM-512; RM-513; RM-514; RM-515; RM-543 RF Troubleshooting Instructions Antenna troubleshooting Antenna troubleshooting diagram Troubleshooting flow Figure 93 Antenna troubleshooting Issue 2 COMPANY CONFIDENTIAL Page 4 –57 Copyright © 2009 Nokia. All rights reserved.
  • Page 128 RM-512; RM-513; RM-514; RM-515; RM-543 RF Troubleshooting Instructions (This page left intentionally blank.) Page 4 –58 COMPANY CONFIDENTIAL Issue 2 Copyright © 2009 Nokia. All rights reserved.
  • Page 129 Nokia Customer Care 5 — Camera Module Troubleshooting Issue 2 COMPANY CONFIDENTIAL Page 5 –1 Copyright © 2009 Nokia. All rights reserved.
  • Page 130 RM-512; RM-513; RM-514; RM-515; RM-543 Camera Module Troubleshooting (This page left intentionally blank.) Page 5 –2 COMPANY CONFIDENTIAL Issue 2 Copyright © 2009 Nokia. All rights reserved.
  • Page 131 Figure 107 Image taken with clean protection window................. 5–15 Figure 108 Image taken with greasy protection window ................5–15 Figure 109 Bit errors caused by JPEG compression..................5–16 Issue 2 COMPANY CONFIDENTIAL Page 5 –3 Copyright © 2009 Nokia. All rights reserved.
  • Page 132 RM-512; RM-513; RM-514; RM-515; RM-543 Camera Module Troubleshooting (This page left intentionally blank.) Page 5 –4 COMPANY CONFIDENTIAL Issue 2 Copyright © 2009 Nokia. All rights reserved.

  • Page 133: Introduction To Camera Module Troubleshooting

    Variation of response between pixels with same level of input illumination. Resolution Usually the amount of pixels in the camera sensor; for example, RM-512/513 has a 640 x 480 pixel sensor resolution. In some occasions the term resolution is used for describing the sharpness of the images. Issue 2 COMPANY CONFIDENTIAL Page 5 –5...

  • Page 134: The Effect Of Image Taking Conditions On Image Quality

    See the figure below for an example. This is normal; do not change the camera module. Page 5 –6 COMPANY CONFIDENTIAL Issue 2 Copyright © 2009 Nokia. All rights reserved.
  • Page 135 This is normal; do not change the camera module. Figure 96 Near objects get skewed when taking images from a moving vehicle Issue 2 COMPANY CONFIDENTIAL Page 5 –7 Copyright © 2009 Nokia. All rights reserved.
  • Page 136 This is normal behaviour; do not change the camera module. Figure 98 Image taken against light Page 5 –8 COMPANY CONFIDENTIAL Issue 2 Copyright © 2009 Nokia. All rights reserved.
  • Page 137 Generally this kind of reflections are common in all optical systems. This is normal behaviour; do not change the camera module. Figure 100 A lens reflection effect caused by sunshine Issue 2 COMPANY CONFIDENTIAL Page 5 –9 Copyright © 2009 Nokia. All rights reserved.

  • Page 138: Camera Construction

    F number/Aperture f/2.74 Focal length 1.78 mm Focus range 20 cm to infinity Still Image resolutions 640x480, 320x240, 160x120 Still images file format EXIF (JPEG), *.jpg Page 5 –10 COMPANY CONFIDENTIAL Issue 2 Copyright © 2009 Nokia. All rights reserved.
  • Page 139 Automatic White Balance Automatic Colours 16.7 million / 24-bit Capture Modes Night mode, Sequence mode, self timer Figure 103 Camera module cross section and assembly principle Issue 2 COMPANY CONFIDENTIAL Page 5 –11 Copyright © 2009 Nokia. All rights reserved.

  • Page 140: Dynamic Camera Configuration

    If the update fails, new camera configuration installed into the terminal is not supported by DP. Always update DCC when a camera or a HWA has been changed. Page 5 –12 COMPANY CONFIDENTIAL Issue 2 Copyright © 2009 Nokia. All rights reserved.

  • Page 141: Image Quality Analysis

    However, it is possible that a larger particle disturbs the user, causing need for service. Issue 2 COMPANY CONFIDENTIAL Page 5 –13 Copyright © 2009 Nokia. All rights reserved.

  • Page 142: Testing Camera Image Sharpness

    3 User has tried to take pictures in too dark conditions, and images are blurred due to handshake or movement. This is no cause to replace camera module. 4 There is dirt between the protection window and camera lens. Page 5 –14 COMPANY CONFIDENTIAL Issue 2 Copyright © 2009 Nokia. All rights reserved.

  • Page 143: Dirty Camera Lens Protection Window

    – 2 meters. • If possible, compare the image to another image of the same scene, taken with a different device. Note that the reference device has to be a similar Nokia phone. Steps 1. Take several images of small objects in the distance of 1-2 metres.

  • Page 144: Camera Troubleshooting Flowcharts

    Camera troubleshooting flowcharts Camera hardware failure message troubleshooting Context If you get a hardware failure message when using the camera, follow the next troubleshooting flowchart. Page 5 –16 COMPANY CONFIDENTIAL Issue 2 Copyright © 2009 Nokia. All rights reserved.
  • Page 145 RM-512; RM-513; RM-514; RM-515; RM-543 Camera Module Troubleshooting Troubleshooting flow Note: Make sure that the phone has the latest software before continuing. Issue 2 COMPANY CONFIDENTIAL Page 5 –17 Copyright © 2009 Nokia. All rights reserved.

  • Page 146: Camera Baseband Hw Troubleshooting

    RM-512; RM-513; RM-514; RM-515; RM-543 Camera Module Troubleshooting Camera baseband HW troubleshooting Troubleshooting flow Page 5 –18 COMPANY CONFIDENTIAL Issue 2 Copyright © 2009 Nokia. All rights reserved.

  • Page 147: Camera Viewfinder Troubleshooting

    RM-512; RM-513; RM-514; RM-515; RM-543 Camera Module Troubleshooting Camera viewfinder troubleshooting Troubleshooting flow Issue 2 COMPANY CONFIDENTIAL Page 5 –19 Copyright © 2009 Nokia. All rights reserved.

  • Page 148: Bad Camera Image Quality Troubleshooting

    RM-512; RM-513; RM-514; RM-515; RM-543 Camera Module Troubleshooting Bad camera image quality troubleshooting Troubleshooting flow Page 5 –20 COMPANY CONFIDENTIAL Issue 2 Copyright © 2009 Nokia. All rights reserved.
  • Page 149 Nokia Customer Care 6 — System Module Issue 2 COMPANY CONFIDENTIAL Page 6 –1 Copyright © 2009 Nokia. All rights reserved.
  • Page 150 RM-512; RM-513; RM-514; RM-515; RM-543 System Module (This page left intentionally blank.) Page 6 –2 COMPANY CONFIDENTIAL Issue 2 Copyright © 2009 Nokia. All rights reserved.
  • Page 151 Table 14 Frequency bands and TX power class ....................6–19 Table 15 Multi-slot class ............................. 6–19 Table 16 Normal and extreme voltages......................6–21 Table 17 Current consumption........................... 6–22 Issue 2 COMPANY CONFIDENTIAL Page 6 –3 Copyright © 2009 Nokia. All rights reserved.
  • Page 152 Figure 116 SIM interface block diagram ......................6–16 Figure 117 BL-5C/Bl-5CA battery pack contacts....................6–17 Figure 118 PWB top side component placement..................... 6–18 Figure 119 PWB bottom side component placement..................6–18 Page 6 –4 COMPANY CONFIDENTIAL Issue 2 Copyright © 2009 Nokia. All rights reserved.

  • Page 153: System Module Block Diagram

    The main board consists of a radio frequency part and a baseband part. The User Interface parts are situated at the UI side. The 2VJ is the engine module of the mobile device. Figure 110 Module block diagram Issue 2 COMPANY CONFIDENTIAL Page 6 –5 Copyright © 2009 Nokia. All rights reserved.

  • Page 154: Baseband Description

    2.78 V LDOs. In addition, the Liteplus contains audio codec, A/D converters, RF converters, many drivers, etc. External regulators White LED Driver solution is implemented with DC/DC converter. The driver circuit is controlled by Liteplus output pin KDLIGHT. Page 6 –6 COMPANY CONFIDENTIAL Issue 2 Copyright © 2009 Nokia. All rights reserved.

  • Page 155: Energy Management

    The Audio circuit: Earpiece, IHF, internal microphone and external speaker are filtered with discrete components (common mode reduction coils, Varistors, caps and resistors), where as the external microphone uses differential mode mic. ASIP Issue 2 COMPANY CONFIDENTIAL Page 6 –7 Copyright © 2009 Nokia. All rights reserved.

  • Page 156: Modes Of Operation

    MIN! Audio function description The basic audio structure and communication between HW-audio modules and the audio ASIC's is illustrated in the block diagram below. Page 6 –8 COMPANY CONFIDENTIAL Issue 2 Copyright © 2009 Nokia. All rights reserved.

  • Page 157: External Audio Connector

    Jack plug, which is integrated in the system connector, contains a mechanical switch, which is used to detect the connection of the accessories. The configuration for the 4-pole Jack-plug is shown in the following figure. Figure 114 4-pole jack plug for audio accessory Issue 2 COMPANY CONFIDENTIAL Page 6 –9 Copyright © 2009 Nokia. All rights reserved.

  • Page 158: Interfaces

    Load Resistance Load Capacitanc ¼ Timing symbo Accuracy TXP2 RF-IC 1.38 1.88 Depends of the RF design (GenIO6 Load Resistance Load Capacitanc ¼ Timing symbo Accuracy Page 6 –10 COMPANY CONFIDENTIAL Issue 2 Copyright © 2009 Nokia. All rights reserved.
  • Page 159 Load resistance Load capacitanc Data frequency GENIO3 Liteplus RF IC 2.78 RF Control * Depends of the RF design Load resistance Output current Issue 2 COMPANY CONFIDENTIAL Page 6 –11 Copyright © 2009 Nokia. All rights reserved.

  • Page 160: Analogue Signals

    Capacitanc Harmonic Content Clear signal mVpp window (no glitch) Duty Cycle RFCLKGnd VCTCXO DC Level System Clock slicer Ref GND, not separated from pwb GND layer Page 6 –12 COMPANY CONFIDENTIAL Issue 2 Copyright © 2009 Nokia. All rights reserved.
  • Page 161 Impedance Output Path powered down impedance Liteplus RF-IC Voltage Min Transmitter power level and ramping (AUXOUT control, Ref Liteplus RF converter Source specification Impedance Resolution bits Issue 2 COMPANY CONFIDENTIAL Page 6 –13 Copyright © 2009 Nokia. All rights reserved.

  • Page 162: Lcd Interface

    A 5 X 4 matrix keyboad consists of 21 keys, one 10-channel integrated passive filter arrays with downstream ESD protection of >8KV connect the matrix keyboard to UPP. Figure 115 Keyboard schematics Page 6 –14 COMPANY CONFIDENTIAL Issue 2 Copyright © 2009 Nokia. All rights reserved.

  • Page 163: Sim Interface

    SIM data (input) 1.8V Vil 0.15xVSIM Trise/Tfall max 3V Vil 0.7xVSI VSIM 3V Vil 0.15xVSIM Not connected Ground VSIM specified in regulator section in this document Issue 2 COMPANY CONFIDENTIAL Page 6 –15 Copyright © 2009 Nokia. All rights reserved.

  • Page 164: External Signals And Connections

    XEARN EAR/ amplifier signal to Amp. accessory. DC biased to 0.8V Switch Liteplu 0/2.7V Dig in HS interrupt from bottom HEADINT connector switch when plug inserted. Page 6 –16 COMPANY CONFIDENTIAL Issue 2 Copyright © 2009 Nokia. All rights reserved.

  • Page 165: Battery Connector

    BSI with an internal resistor. The BSI fixed resistor value indicates type and default capacity of a battery. Figure 117 BL-5C/Bl-5CA battery pack contacts Table 13 Pin numbering of battery pack Signal name Pin number Function Negative/common battery terminal Issue 2 COMPANY CONFIDENTIAL Page 6 –17 Copyright © 2009 Nokia. All rights reserved.

  • Page 166: Pwb Outline

    Figure 118 PWB top side component placement Figure 119 PWB bottom side component placement RF description Frequency band, power and multi-slot class The requirement leads to the specification in the table below: Page 6 –18 COMPANY CONFIDENTIAL Issue 2 Copyright © 2009 Nokia. All rights reserved.

  • Page 167: Transmitter - General Description

    Receiver - general description The receiver is a direct conversion linear receiver. It is a dual-band receiver with receiver paths for either GSM850/1900 or GSM900/1800 configuration. Issue 2 COMPANY CONFIDENTIAL Page 6 –19 Copyright © 2009 Nokia. All rights reserved.

  • Page 168: Vcxo And Pll

    Dimension LxWxT Weight (g) Volume (cc) Note (mm) Transceiver with 106.9x46x13.8 79.87 RM-512/513 BL-5C 1020mAh/ 106.9x46x13.7 57.8 RM-514/515 BL-5CA 700mAh Li- 106.9x46x13.7 RM-543 Ion battery pack Page 6 –20 COMPANY CONFIDENTIAL Issue 2 Copyright © 2009 Nokia. All rights reserved.

  • Page 169: Battery Endurance

    RM-512; RM-513; RM-514; RM-515; RM-543 System Module Battery endurance Nokia measurements of operation times in GSM900/1800 Talk time Battery: BL-5C 1020mAh/BL-5CA 700mAh 500 mins/350 mins Standby time Battery: BL-5C 1020mAh/BL-5CA 700mAh 537 hours/368 hours Note: Variation in operation times will occur depending on SIM card, network settings and usage.
  • Page 170 The minimum battery cell voltage required for the reset circuitry to turn on. This is not confirmed by measures at pt. Table 17 Current consumption Condition Typical Unit Call (MoU) (E)GSM 900 GSM 1800 GSM 1900 Idle (MoU) Power off Page 6 –22 COMPANY CONFIDENTIAL Issue 2 Copyright © 2009 Nokia. All rights reserved.
  • Page 171 Nokia Customer Care Glossary Issue 2 COMPANY CONFIDENTIAL Page Glossary–1 Copyright © 2009 Nokia. All rights reserved.
  • Page 172 RM-512; RM-513; RM-514; RM-515; RM-543 Glossary (This page left intentionally blank.) Page Glossary–2 COMPANY CONFIDENTIAL Issue 2 Copyright © 2009 Nokia. All rights reserved.
  • Page 173 Clock Timing Sleep and interrupt block of Tiku Continuous wave D/A-converter Digital-to-analogue converter Digital-to-analogue converter Digital Battery Interface DBus DSP controlled serial bus connected between UPP_WD2 and Helgo Issue 2 COMPANY CONFIDENTIAL Page Glossary–3 Copyright © 2009 Nokia. All rights reserved.
  • Page 174 High speed circuit switched data (data transmission connection faster than GSM) Hardware Input/Output IBAT Battery current Integrated circuit ICHAR Charger current Interface Integrated hands free IMEI International Mobile Equipment Identity Infrared Page Glossary–4 COMPANY CONFIDENTIAL Issue 2 Copyright © 2009 Nokia. All rights reserved.
  • Page 175 Phase locked loop (Phone) Permanent memory General Purpose IO (PIO), USARTS and Pulse Width Modulators PURX Power-up reset Printed Wiring Board Pulse width modulation RC-filter Resistance-Capacitance filter Radio Frequency Issue 2 COMPANY CONFIDENTIAL Page Glossary–5 Copyright © 2009 Nokia. All rights reserved.
  • Page 176 UPnP Universal Plug and Play Universal Phone Processor UPP_WD2 Communicator version of DCT4 system ASIC Universal Serial Bus VBAT Battery voltage VCHAR Charger voltage Voltage controlled oscillator Page Glossary–6 COMPANY CONFIDENTIAL Issue 2 Copyright © 2009 Nokia. All rights reserved.
  • Page 177 Wideband code division multiple access Watchdog WLAN Wireless local area network XHTML Extensible hypertext markup language Zocus Current sensor (used to monitor the current flow to and from the battery) Issue 2 COMPANY CONFIDENTIAL Page Glossary–7 Copyright © 2009 Nokia. All rights reserved.
  • Page 178 RM-512; RM-513; RM-514; RM-515; RM-543 Glossary (This page left intentionally blank.) Page Glossary–8 COMPANY CONFIDENTIAL Issue 2 Copyright © 2009 Nokia. All rights reserved.

This manual is also suitable for:

Rm-513Rm-514Rm-515Rm-54323302320 ... Show all

Table of Contents