Table of Contents
Advertisement
QQ
3 7 63 1515 0
SERVICE MANUAL
Ver. 1.2 2007.06
HCD-DZ20 is the amplifier, DVD/CD and
tuner section in DAV-DZ20.
This system incorporates with Dolby* Digital and Dolby Pro Logic (II) adaptive
matrix surround decoder and the DTS** Digital Surround System.
* Manufactured under license from Dolby Laboratories.
"Dolby", "Pro Logic", and the double-D symbol are trademarks of Dolby
Laboratories.
** Manufactured under license from DTS, Inc.
"DTS" and "DTS Digital Surround" are registered trademarks of DTS, Inc.
TE
L 13942296513
Amplifier section
Stereo mode (rated)
Surround mode (reference) RMS output power
* Depending on the sound field settings and the source,
there may be no sound output.
Inputs (Analog)
TV (AUDIO IN)(AEP, UK models)
TV/VIDEO (AUDIO IN)(Except AEP, UK models)
DVD system
Laser
Signal format system
Mexican and Latin American models:
Other models:
www
.
Sony Corporation
9-887-568-03
Home Audio Division
2007F16-1
Published by Sony Techno Create Corporation
© 2007.06
http://www.xiaoyu163.com
Tuner section
50 W + 50 W (at 3 ohms,
System
1 kHz, 1 % THD)
FM tuner section
FL/FR/C/SL/SR*: 67 watts
Tuning range
(per channel at 3 ohms,
1 kHz, 10 % THD)
Antenna (aerial)
Subwoofer*: 65 watts (at 3
Antenna (aerial) terminals 75 ohms, unbalanced
ohms, 80 Hz, 10 % THD)
Intermediate frequency
AM tuner section
Tuning range
Mexican and Latin American models:
Sensitivity: 450/250 mV
European, Russian and Middle Eastern models:
Sensitivity: 450/250 mV
Semiconductor laser
Other models:
(DVD: λ = 650 nm)
(CD: λ = 790 nm)
Emission duration:
Antenna (aerial)
continuous
Intermediate frequency
NTSC
NTSC/PAL
x
ao
u163
y
i
http://www.xiaoyu163.com
HCD-DZ20
2 9
8
Model Name Using Similar Mechanism
Mechanism Type
Optical Pick-up Name
Q Q
3
6 7
1 3
1 5
SPECIFICATIONS
PLL quartz-locked digital
synthesizer
87.5-108.0 MHz (50 kHz
step)
FM wire antenna (aerial)
10.7 MHz
530 – 1,710 kHz (with the
interval set at 10 kHz)
531 – 1,710 kHz (with the
interval set at 9 kHz)
531 – 1,602 kHz (with the
interval set at 9 kHz)
531 – 1,602 kHz (with the
interval set at 9 kHz)
530 – 1,610 kHz (with the
interval set at 10 kHz)
AM loop antenna (aerial)
450 kHz
co
.
9 4
2 8
AEP Model
UK Model
E Model
HCD-DZ230
CDM85-DVBU102
KHM-313CAA
0 5
8
2 9
9 4
2 8
Video section
Outputs
AEP, UK models:
VIDEO: 1 Vp-p 75 ohms
R/G/B: 0.7 Vp-p 75 ohms
Except AEP, UK models: VIDEO: 1 Vp-p 75 ohms
S VIDEO:
Y: 1 Vp-p 75 ohms
C: 0.286 Vp-p 75 ohms
COMPONENT:
Y: 1 Vp-p 75 ohms
P
/C
, P
B
B
75 ohms
General
Power requirements
Mexican models:
120 V AC, 60 Hz
Argentine models:
220 - 240 V AC, 50/60 Hz
Latin American models:
110 - 240 V AC, 50/60 Hz
Other models:
220 - 240 V AC, 50/60 Hz
Power consumption
On: 80 W
Standby: 0.3 W (at the
Power Saving mode)
430 × 67 × 310 mm (w/h/d)
Dimensions (approx.)
incl. projecting parts
Mass (approx.)
3.2 kg
Design and specifications are subject to change
without notice.
m
DVD RECEIVER
9 9
9 9
/C
: 0.7 Vp-p
R
R
Advertisement
Table of Contents
Related Manuals for Sony HCD-DZ20
Summary of Contents for Sony HCD-DZ20
-
Page 1: Service Manual
SERVICE MANUAL AEP Model UK Model E Model Ver. 1.2 2007.06 HCD-DZ20 is the amplifier, DVD/CD and tuner section in DAV-DZ20. This system incorporates with Dolby* Digital and Dolby Pro Logic (II) adaptive Model Name Using Similar Mechanism HCD-DZ230 matrix surround decoder and the DTS** Digital Surround System. - Page 2 Strictly follow the instructions whenever the components are repaired THE PARTS LIST ARE CRITICAL TO SAFE OPERATION. u163 and/or replaced. REPLACE THESE COMPONENTS WITH SONY PARTS WHOSE PART NUMBERS APPEAR AS SHOWN IN THIS MANUAL OR IN SUPPLEMENTS PUBLISHED BY SONY. http://www.xiaoyu163.com...
-
Page 3: Table Of Contents
HCD-DZ20 3 7 63 1515 0 TABLE OF CONTENTS SERVICING NOTE 6-4. Block Diagram – AMP Section – ........29 ........... 4 6-5. Block Diagram – POWER Section – ......30 6-6. Printed Wiring Board – MAIN Board (Side A) – ... 31 GENERAL .............. -
Page 4: Servicing Note
HCD-DZ20 SECTION 1 3 7 63 1515 0 SERVICING NOTE Note about CDs/DVDs NOTES ON HANDLING THE OPTICAL PICK-UP BLOCK The system can play CD-ROMs/CD-Rs/CD-RWs recorded in the OR BASE UNIT following formats: – audio CD format The laser diode in the optical pick-up block may suffer electrostatic –... -
Page 5: Http://Www.xiaoyu163.Com
TV screen. Although this is not a character service number (e.g., C 13 50) with a malfunction and for Sony service use only, combination of a letter and 4 digits appears on normal system operation will not be possible. - Page 6 HCD-DZ20 3 7 63 1515 0 Prevention of electric shock and damage to IC When disassembling the machine, be sure to discharge the charged electricity in the below point. Use a resistor of 800 ohms, 2 Watts for discharging.
- Page 7 HCD-DZ20 3 7 63 1515 0 MAIN board service position Please take the above-mentioned position in the repair of MAIN board. In that case, it is necessary the following extension cable during CN801 on FL board and CN509 on MAIN board.
-
Page 8: General
HCD-DZ20 SECTION 2 3 7 63 1515 0 GENERAL This section is extracted from instruction manual. Front panel A "/1 (on/standby) (18) (remote sensor) (8) G VOLUME control (18) B A (open/close) (18) H Disc tray (18) C Disc operation (18) - Page 9 HCD-DZ20 3 7 63 1515 0 ont panel display About the indications in the front panel display AEP, UK MODEL A Lights up when the time information of I Lights up when the child lock function a title or chapter appears in the front is set to on.
- Page 10 HCD-DZ20 3 7 63 1515 0 Remote control ALPHABETICAL ORDER BUTTON DESCRIPTIONS [/1 (on/standby) 1 (13, 16, 18, A – O P – Z 26, 48) ANGLE 5 (36) PICTURE NAVI 6 (26, 50) TV [/1 (on/standby) ej (50) AUDIO 4 (31) PRESET +/–...
-
Page 11: Disassembly
HCD-DZ20 Ver. 1.1 SECTION 3 3 7 63 1515 0 DISASSEMBLY 3-1. DISASSEMBLY FLOW • This set can be disassembled in the order shown below. 3-2. CASE (Page 12) 3-3. FRONT PANEL ASSY (Page 12) 3-9. DVD MECHANISM DECK 3-7. -
Page 12: Case
HCD-DZ20 3 7 63 1515 0 3-2. CASE 4 case 2 screw (CASE3 TP2) 3 five screws (+BVTP 3 × 8) 1 screw (CASE3 TP2) L 13942296513 3-3. FRONT PANEL ASSY 1 The lever is moved in the direction of the arrow with the thin rod. -
Page 13: Fl Board
HCD-DZ20 3 7 63 1515 0 3-4. FL BOARD 7 wire (flat type) 15core (CN801) 6 connector 6p (CN805) 8 FL board 5 two screws (+BVTP 2.6 × 10) 4 shield (front) 3 three screws (+BVTP 2.6 × 10) -
Page 14: Main Board
HCD-DZ20 Ver. 1.1 3 7 63 1515 0 3-6. MAIN BOARD 1 two screws (+BV 3 × 10) 2 screw (+BVTP 3 × 12) Attaching the two radiation sheets on the IC MAIN board first, and then attach the heatsink (AMP). -
Page 15: Tuner (Fm/Am), Io Board (Aep, Uk)
HCD-DZ20 Ver. 1.1 3 7 63 1515 0 3-7. TUNER (FM/AM), IO BOARD (AEP, UK) 3 tuner (FM/AM) 1 wire (flat type) 11core 6 wire (flat type) 11core (CN101) 2 two screws (+BVTT 2.6 × 6) 8 IO board 7 two screws (+BVTP 3 ×... -
Page 16: Dvd Mechanism Deck (Cdm85-Dvbu102)
HCD-DZ20 3 7 63 1515 0 3-9. DVD MECHANISM DECK (CDM85-DVBU102) 7 three screws (+BV 3 × 6) 8 Remove the DVD mechanism deck (CDM85-DVBU102) 1 The lever is moved in the direction in the direction of the arrow. -
Page 17: Belt, Ms-203 Board
HCD-DZ20 3 7 63 1515 0 3-11. BELT, MS-203 BOARD 2 chuck cam 3 belt 4 screw (M 1.7 × 2.5) L 13942296513 1 two claws 7 MS-203 board 6 DC motor 5 three claws u163 http://www.xiaoyu163.com... -
Page 18: Optical Pick-Up (Khm-313Caa)
HCD-DZ20 3 7 63 1515 0 3-12. OPTICAL PICK-UP (KHM-313CAA) 3 two claws 2 chuck cam 1 two claws 4 base unit L 13942296513 8 two insulators 6 four insulator screws 9 two insulators 0 optical pick-up (KHM-313CAA) u163... -
Page 19: Test Mode
HCD-DZ20 SECTION 4 3 7 63 1515 0 TEST MODE 3. Disc Tray Lock Note: Incorrect operations may be performed if the test mode is not The disc tray lock function for the antitheft of an demonstration entered properly. -
Page 20: Http://Www.xiaoyu163.Com
HCD-DZ20 3 7 63 1515 0 (2) Select “2. Drive Manual Operation” by pressing the 2 button DVD SECTION on the remote commander. The screen will appear as shown. 7-1. GENERAL DESCRIPTION Drive Manual Operation The IOP measurement allows you to make diagnosis and adjustment 1. -
Page 21: Http://Www.xiaoyu163.Com
HCD-DZ20 3 7 63 1515 0 7-4. EMERGENCY HISTORY 52: Open kick spindle error To check the emergency history, please follow the following 51: Spindle stop error procedure. 60: Focus on error 61: Seek fail error (1) From the Top Menu of Remocon Diagnosis Menu, select “3. -
Page 22: Http://Www.xiaoyu163.Com
HCD-DZ20 3 7 63 1515 0 7-4-4. Return to the Top Menu of Remocon Diagnosis 10. PROTECTION FACTOR (SD DETECTION/ Menu DC DETECTION) IDENTIFICATION TEST MODE Press 0 button on the remote commander. When an error is detected, the FL tube alternately displays “PROTECTOR h PUSH POWER”. -
Page 23: Electrical Adjustments
HCD-DZ20 SECTION 5 3 7 63 1515 0 ELECTRICAL ADJUSTMENT DVD SECTION When the optical pick-up assy is replaced, perform the “EXECUTING IOP MEASUREMENT”. EXECUTING IOP MEASUREMENT (See page 20) TUNER SECTION [FM Tune Level Check] generator OUT (75 Ω ) Procedure: 1. -
Page 24: Diagrams
HCD-DZ20 Ver. 1.2 SECTION 6 3 7 63 1515 0 DIAGRAMS THIS NOTE IS COMMON FOR PRINTED WIRING BOARDS AND SCHEMATIC DIAGRAMS. (In addition to this, the necessary note is printed in each block.) For Schematic Diagrams. For Printed Wiring Boards. - Page 25 HCD-DZ20 3 7 6 3 1 5 1 5 0 • Circuit Boards Location • Waveforms – MAIN Board – – IO Board – IC1101 6 (DVDRFIP) IC201 wd (CVBS) 1.0 Vp-p TUNER (FM/AM) 900 mVp-p IO board 200 mV/DIV, 100 ns/DIV 500 mV/DIV, 20 µ...
-
Page 26: Block Diagram - Rf Section
HCD-DZ20 6-1. BLOCK DIAGRAM – RF SECTION – 3 7 6 3 1 5 1 5 0 DVDRFIP DVDA DVDB DETECTOR DVDC DVDD IC1101 (1/3) CD/DVD RF AMP, OPTICAL PICK-UP FOCUS/TRACKING ERROR AMP BLOCK • Signal Path DVD SYSTEM PROCESSOR... -
Page 27: Block Diagram - Video Section
HCD-DZ20 6-2. BLOCK DIAGRAM – VIDEO SECTION – 3 7 6 3 1 5 1 5 0 AEP, UK J203 CROUT R/C OUT CYOUT G OUT CBOUT B OUT VOUT IC201 V/Y OUT VIDEO AMP, 75Ω DRIVER EURO AV... -
Page 28: Block Diagram - Audio Section
HCD-DZ20 6-3. BLOCK DIAGRAM – AUDIO SECTION – 3 7 6 3 1 5 1 5 0 IC2200 A/D CONVERTER DATA1 – DATA3, ACLK, 13 LIN DOUT ABCK, ALRCK ALRCK SECTION ABCK (Page 29) R-CH 14 RIN SCKI DATA1... -
Page 29: Block Diagram - Amp Section
HCD-DZ20 6-4. BLOCK DIAGRAM – AMP SECTION – 3 7 6 3 1 5 1 5 0 • Signal Path : AUDIO IC3100 IC3010 SPEAKER POWER DRIVER SYSTEM PROCESSOR DATA1 - DATA3, ACLK, ABCK, ALRCK DATA1 AUDIO 31 DATA... -
Page 30: Block Diagram - Power Section
HCD-DZ20 6-5. BLOCK DIAGRAM – POWER SECTION – 3 7 6 3 1 5 1 5 0 T901 D901 TRANSFORMER(MAIN) AC IN D931 IC901 D905 +21.7V Q901 SWITCHING DC/DC VOLTAGE REGULATOR CONVERTER CONTROLLER IC931 T801 VOLTAGE DETECT PC901 TO FLUORESCENT... -
Page 31: Printed Wiring Board - Main Board (Side A)
HCD-DZ20 Ver. 1.2 • See page 25 for Circuit Boards Location. 6-6. PRINTED WIRING BOARD – MAIN BOARD (SIDE A) – :Uses unleaded solder. 3 7 6 3 1 5 1 5 0 MAIN BOARD (SIDE A) • Semiconductor Location Ref. -
Page 32: Printed Wiring Board - Main Board (Side B)
HCD-DZ20 Ver. 1.1 • See page 25 for Circuit Boards Location. 6-7. PRINTED WIRING BOARD – MAIN BOARD (SIDE B) – :Uses unleaded solder. 3 7 6 3 1 5 1 5 0 SPEAKER CENTER WOOFER FRONT R FRONT L... -
Page 33: Schematic Diagram - Main Board (1/8)
HCD-DZ20 • See page 25 for Waveforms. • See page 49 for IC Pin Function Description. 6-8. SCHEMATIC DIAGRAM – MAIN BOARD (1/8) – 3 7 6 3 1 5 1 5 0 MAIN BOARD (1/8) R1183 R1132 100k... -
Page 34: Schematic Diagram - Main Board (2/8)
HCD-DZ20 Ver. 1.2 • See page 46 for IC Block Diagram. 6-9. SCHEMATIC DIAGRAM – MAIN BOARD (2/8) – 3 7 6 3 1 5 1 5 0 (CHASSIS) CN1301 MAIN BOARD JL1713 IC1104 (2/8) C1197 V-GND JL1711 64M SDRAM... -
Page 35: Schematic Diagram - Main Board (3/8)
HCD-DZ20 Ver. 1.2 • See page 25 for Waveform. • See page 54 for IC Pin Function Description. 6-10. SCHEMATIC DIAGRAM – MAIN BOARD (3/8) – 3 7 6 3 1 5 1 5 0 MAIN BOARD (3/8) D-GND... -
Page 36: Schematic Diagram - Main Board (4/8)
HCD-DZ20 • See page 46 for IC Block Diagram. 6-11. SCHEMATIC DIAGRAM – MAIN BOARD (4/8) – 3 7 6 3 1 5 1 5 0 (4/8) MAIN BOARD C3401 Q3551 2SC3052EF-T1-LEF PROTECT DETECT IC3400 IC3400 CXD9774M ICT360 12.0... -
Page 37: Schematic Diagram - Main Board (5/8)
HCD-DZ20 • See page 46 for IC Block Diagram. 6-12. SCHEMATIC DIAGRAM – MAIN BOARD (5/8) – 3 7 6 3 1 5 1 5 0 MAIN BOARD (4/8) (Page 36) MAIN BOARD (5/8) C3251 IC3250 CXD9774M IC3250 12.0... -
Page 38: Schematic Diagram - Main Board (6/8)
HCD-DZ20 • See page 25 for Waveform. • See page 46 for IC Block Diagrams. 6-13. SCHEMATIC DIAGRAM – MAIN BOARD (6/8) – 3 7 6 3 1 5 1 5 0 MAIN BOARD (5/8) (Page 37) C3151 MAIN BOARD (6/8) -
Page 39: Schematic Diagram - Main Board (7/8)
HCD-DZ20 6-14. SCHEMATIC DIAGRAM – MAIN BOARD (7/8) – 3 7 6 3 1 5 1 5 0 MAIN BOARD (7/8) MAIN BOARD SW+5V (3/8) (Page 35) IOPMON R1223 R1225 R1231 R1234 100k 100k ICT550 FCS- R1233 C1209 R1230... -
Page 40: Schematic Diagram - Main Board (8/8)
HCD-DZ20 Ver. 1.2 • See page 47 for IC Block Diagram. 6-15. SCHEMATIC DIAGRAM – MAIN BOARD (8/8) – 3 7 6 3 1 5 1 5 0 (CHASSIS) (CHASSIS) MAIN BOARD (8/8) TH901 C905 C938 THERMISTOR, NTC 3.0: MX, E32 470p 0.0033, 400V: EXCEPT MX... -
Page 41: Printed Wiring Board - Ms-203 Board
HCD-DZ20 • See page 25 for Circuit Boards Location. 6-16. PRINTED WIRING BOARD – MS-203 BOARD – 6-17. SCHEMATIC DIAGRAM – MS-203 BOARD – 3 7 6 3 1 5 1 5 0 :Uses unleaded solder. MS-203 BOARD CN001... -
Page 42: Printed Wiring Board - Io Board
HCD-DZ20 Ver. 1.1 • See page 25 for Circuit Boards Location. 6-18. PRINTED WIRING BOARD – IO BOARD – :Uses unleaded solder. 3 7 6 3 1 5 1 5 0 IO BOARD • Semiconductor Location Ref. No. Location... -
Page 43: Schematic Diagram - Io Board
HCD-DZ20 Ver. 1.1 • See page 25 for Waveforms. • See page 47 for IC Block Diagram. 6-19. SCHEMATIC DIAGRAM – IO BOARD – 3 7 6 3 1 5 1 5 0 AEP, UK EXCEPT AEP, UK COAXIAL... -
Page 44: Printed Wiring Boards - Key, Fl, P-Sw Board
HCD-DZ20 • See page 25 for Circuit Boards Location. 6-20. PRINTED WIRING BOARDS – KEY, FL, P-SW BOARD – :Uses unleaded solder. 3 7 6 3 1 5 1 5 0 MAIN BOARD CN509 FL BOARD (Page 32) R805... -
Page 45: Schematic Diagram - Key, Fl, P-Sw Board
HCD-DZ20 • See page 48 for IC Block Diagram. 6-21. SCHEMATIC DIAGRAM – KEY, FL, P-SW BOARD – 3 7 6 3 1 5 1 5 0 R857 KEY BOARD R856 R855 2.2K 2.2k S806 S805 S804 C853 CN809... - Page 46 HCD-DZ20 3 7 6 3 1 5 1 5 0 • IC Block Diagrams – MAIN Board – IC2200 PCM1808PWR IC3010, IC3020, IC3030 CXD9843AR Serial LRCK Interface DOUT Mode/ Format Control OVF FLAG L Serial Control Clock SFLAG Timing...
- Page 47 HCD-DZ20 3 7 63 1515 0 – MAIN Board – IC901 STR-F6138-LF1352 FB/OLP Reg2 Drain UVL0 Delay POWER ON=16V – MOS FET OFF=10.5V Delay Reg1 IOLP Latch Internal S/GND – Bias OCP1 Volp – Vocp INH1 – Boottom Skip...
- Page 48 HCD-DZ20 3 7 63 1515 0 – FL Board – IC802 uPD16315GB-3BS Grid driver Multiplexed driver SEG19/GRID10 Command decoder LED1 SEG18/GRID11 LED2 Display memory LED3 SEG17/GRID12 24 bits x 12 words LED4 Timing generator key scan DOUT SEG16/KS16 L 13942296513...
- Page 49 HCD-DZ20 3 7 63 1515 0 • IC Pin Function Description MAIN BOARD IC1101 CXD9849R (CD/DVD RF AMP, FOCUS/TRACKING ERROR AMP, DVD SYSTEM PROCESSOR, DIGITAL SERVO PROCESSOR) Pin No. Pin Name Description AGND — Ground terminal DVDA AC coupled input path A...
- Page 50 HCD-DZ20 3 7 63 1515 0 Pin No. Pin Name Description DSEL — Not used WIDE SI signal output to VIDEO AMP (IC201) DVD/CD select signal output MAMUTE MAMUTE signal output to System Controller (not used (Open)) DVDD18 —...
- Page 51 HCD-DZ20 3 7 63 1515 0 Pin No. Pin Name Description DQMO DQM0 signal output to SD-RAM (IC1104) MREQ DQM signal output (not used (Open)) Data bus 7 from SD-RAM (IC1104) DVSS — Ground terminal 117, 118 RD 6, 5...
- Page 52 HCD-DZ20 3 7 63 1515 0 Pin No. Pin Name Description OCSW OCSW signal input REW signal output to Motor driver (IC1201) CKSW CKSW signal input — Not used (Open) — Not used (Open) DVDD3 — Power Supply (+3.3V) —...
- Page 53 HCD-DZ20 3 7 63 1515 0 Pin No. Pin Name Description RFGND18 — Ground terminal RFVDD18 — Power Supply (+1.8V) XTALO Oscillator output signal XTALI Oscillator input signal JITFO RF jitter meter output JITFN Negative input of operation amplifier for RF jitter meter PLLVSS —...
- Page 54 HCD-DZ20 3 7 63 1515 0 MAIN BOARD IC501 M30622MEP-B20FPU0 (SYSTEM CONTROLLER) Pin No. Pin Name Description DAMP_SCDT Digital amp (IC3010, 3020, 3030) data output DAMP_SHIFT Digital amp (IC3010, 3020, 3030) data output NO USE Not used (Open) SIRCS_IN...
- Page 55 HCD-DZ20 3 7 63 1515 0 Pin No. Pin Name Description DAMP_LATCH3 Digital amp (IC3030) chip select1 signal output DAMP_INIT Digital amp (IC3010, 3020, 3030) reset signal output DAMP_SOFT_MUTE Digital amp (IC3010, 3020, 3030) soft muting output HP_SW Headphone detect input (not used (Fixed to “L”))
- Page 56 HCD-DZ20 3 7 63 1515 0 Pin No. Pin Name Description AVSS — Ground terminal KEY0 Key input 0 VREF — Reference Voltage (+3.3V) — Power supply (+3.3V) NO USE Not used (Open) L 13942296513 u163 http://www.xiaoyu163.com...
-
Page 57: Exploded Views
HCD-DZ20 Ver. 1.2 SECTION 7 3 7 63 1515 0 EXPLODED VIEWS NOTE: • -XX and -X mean standardized parts, so they • Abbreviation The components identified by mark 0 or may have some difference from the original : Argentine model dotted line with mark 0 are critical for safety. -
Page 58: Front Panel Assy
HCD-DZ20 3 7 63 1515 0 7-2. FRONT PANEL ASSY supplied supplied supplied supplied supplied supplied supplied including S800 L 13942296513 Ref. No. Part No. Description Remark Ref. No. Part No. Description Remark 2-889-990-11 KNOB (VOL) 2-892-571-21 PANEL, FRONT (EXCEPT AEP, UK) -
Page 59: Dvd Mechanism Deck Section (Cdm85-Dvbu102)
HCD-DZ20 3 7 63 1515 0 7-3. DVD MECHANISM DECK SECTION (CDM85-DVBU102) not supplied not supplied not supplied not supplied not supplied not supplied not supplied not supplied L 13942296513 supplied Ref. No. Part No. Description Remark Ref. No. -
Page 60: Electrical Parts List
HCD-DZ20 Ver. 1.2 SECTION 8 3 7 63 1515 0 ELECTRICAL PARTS LIST NOTE: • Due to standardization, replacements in the • RESISTORS When indicating parts by reference number, parts list may be different from the parts All resistors are in ohms. - Page 61 HCD-DZ20 Ver. 1.1 3 7 63 1515 0 Ref. No. Part No. Description Remark Ref. No. Part No. Description Remark C227 1-126-933-11 ELECT 100uF IC603 8-759-100-96 IC uPC4558G2 (EXCEPT AEP, UK) C228 1-126-916-11 ELECT 1000uF 6.3V < JACK >...
- Page 62 HCD-DZ20 Ver. 1.2 MAIN 3 7 63 1515 0 Ref. No. Part No. Description Remark Ref. No. Part No. Description Remark R249 1-216-821-11 METAL CHIP 1/10W KEY BOARD (AEP, UK) ********* R250 1-216-825-11 METAL CHIP 2.2K 1/10W (AEP, UK) <...
- Page 63 HCD-DZ20 Ver. 1.2 MAIN 3 7 63 1515 0 Ref. No. Part No. Description Remark Ref. No. Part No. Description Remark 0 C963 1-117-697-51 CERAMIC 470PF 250V C592 1-162-964-11 CERAMIC CHIP 0.001uF (EXCEPT MX) C595 1-107-826-11 CERAMIC CHIP 0.1uF...
- Page 64 HCD-DZ20 MAIN 3 7 63 1515 0 Ref. No. Part No. Description Remark Ref. No. Part No. Description Remark C1162 1-162-970-11 CERAMIC CHIP 0.01uF C3013 1-164-156-11 CERAMIC CHIP 0.1uF C1163 1-162-970-11 CERAMIC CHIP 0.01uF C3014 1-164-156-11 CERAMIC CHIP 0.1uF...
- Page 65 HCD-DZ20 MAIN 3 7 63 1515 0 Ref. No. Part No. Description Remark Ref. No. Part No. Description Remark C3155 1-164-346-11 CERAMIC CHIP C3311 1-100-436-91 CERAMIC CHIP 0.033uF C3156 1-100-436-91 CERAMIC CHIP 0.033uF C3314 1-136-177-00 FILM C3315 1-136-177-00 FILM...
- Page 66 HCD-DZ20 Ver. 1.2 MAIN 3 7 63 1515 0 Ref. No. Part No. Description Remark Ref. No. Part No. Description Remark 0 D926 6-501-174-01 DIODE UDZW-TE17-10B IC3250 6-704-802-01 IC CXD9774M D931 6-501-849-01 DIODE FMX-22SL D932 6-501-167-01 DIODE UDZW-TE17-5.1B IC3300...
- Page 67 HCD-DZ20 Ver. 1.2 MAIN 3 7 63 1515 0 Ref. No. Part No. Description Remark Ref. No. Part No. Description Remark < TRANSISTOR > R522 1-216-833-11 METAL CHIP 1/10W R523 1-216-833-11 METAL CHIP 1/10W Q502 6-550-363-01 TRANSISTOR 2SB1690KT146 R524...
- Page 68 HCD-DZ20 MAIN 3 7 63 1515 0 Ref. No. Part No. Description Remark Ref. No. Part No. Description Remark 0 R919 1-216-836-11 METAL CHIP 1/10W R1123 1-216-864-11 SHORT CHIP 0 R922 1-216-793-11 METAL CHIP 1/10W R1124 1-216-841-11 METAL CHIP...
- Page 69 HCD-DZ20 MAIN 3 7 63 1515 0 Ref. No. Part No. Description Remark Ref. No. Part No. Description Remark R1238 1-216-829-11 METAL CHIP 4.7K 1/10W R3052 1-216-857-11 METAL CHIP 1/10W R1239 1-216-829-11 METAL CHIP 4.7K 1/10W R3053 1-216-809-11 METAL CHIP...
- Page 70 HCD-DZ20 MAIN MS-203 P-SW 3 7 63 1515 0 Ref. No. Part No. Description Remark Ref. No. Part No. Description Remark R3176 1-216-845-11 METAL CHIP 100K 1/10W R3427 1-216-845-11 METAL CHIP 100K 1/10W R3554 1-216-845-11 METAL CHIP 100K 1/10W...
- Page 71 HCD-DZ20 Ver. 1.2 P-SW 3 7 63 1515 0 Ref. No. Part No. Description Remark < SWITCH > S801 1-762-875-21 SWITCH, KEYBOARD (?/1) ************************************************************* MISCELLANEOUS ************** 1-828-286-51 WIRE (FLAT TYPE) (5 CORE) 1-828-350-51 WIRE (FLAT TYPE)(17 CORE) (AEP, UK)
- Page 72 HCD-DZ20 3 7 63 1515 0 REVISION HISTORY Clicking the version allows you to jump to the revised page. Also, clicking the version at the top of the revised page allows you to jump to the next revised page.