hit counter script
Sony STR-DH130 Service Manual
  1. Manuals
  2. Brands
  3. Sony Manuals
  4. Stereo Receiver
  5. STR-DH130
  6. Service manual

Sony STR-DH130 Service Manual

Fm stereo/fm-am receiver
Hide thumbs Also See for STR-DH130:
Table of Contents

Advertisement

Quick Links

SERVICE MANUAL
Ver. 1.0 2012.01
Specifi cations
AUDIO POWER
SPECIFICATIONS
POWER OUTPUT AND TOTAL
HARMONIC DISTORTION:
(US model only)
With 8 ohm loads, both channels driven, from
20 – 20,000 Hz; rated 90 watts per channel
minimum RMS power, with no more than 0.09%
total harmonic distortion from 250 milliwatts to
rated output.
Amplifi er section
US, Canadian and AEP models
1)
Minimum RMS Output Power (8 ohms, 20 Hz –
20 kHz, THD 0.09%)
90 W + 90 W
Stereo Mode Output Power (8 ohms, 1 kHz,
THD 1%)
100 W + 100 W
Measured under the following conditions:
1)
Area
Power requirements
US, Canadian
120 V AC, 60 Hz
AEP
230 V AC, 50 Hz
Frequency response
Analog
10 Hz – 70 kHz
+0.5/–2 dB (with BASS =
0 dB, TREBLE = 0 dB)
Input
Analog (PORTABLE IN)
Sensitivity: 1 V/
50 kilohms
S/N
2)
: 96 dB (A, 500 mV
Inputs
Analog (Except PORTABLE IN)
Sensitivity: 500 mV/
50 kilohms
S/N
2)
: 96 dB (A, 500 mV
Outputs
Analog (AUDIO OUT)
Voltage: 500 mV/
10 kilohms
9-890-596-01
Sony Corporation
2012A08-1
©
2012.01
Published by Sony EMCS (Malaysia) PG Tec
STR-DH130
Tone
Gain levels
±10 dB, 1 dB step
INPUT SHORT (with BASS = 0 dB, TREBLE =
2)
0 dB).
3)
Weighted network, input level.
FM tuner section
Tuning range
87.5 MHz – 108.0 MHz
Antenna (aerial)
FM wire antenna (aerial)
Antenna (aerial) terminals
75 ohms, unbalanced
AM tuner section
Tuning range
Area
Tuning scale
10 kHz step
US, Canadian
530 kHz –
1,710 kHz
–
AEP
Antenna (aerial)
Loop antenna (aerial)
General
Power requirements
Area
Power requirements
US, Canadian
120 V AC, 60 Hz
AEP
230 V AC, 50/60 Hz
Power consumption 200 W
Power consumption (during standby mode)
0.3 W
Dimensions (w/h/d) (Approx.)
430 mm × 132.5 mm ×
279 mm (17 in × 5 1/4 in ×
11 in) including projecting
parts and controls
Mass (Approx.)
6.4 kg (14 lb 2 oz)
3)
)
3)
)
Canadian Model
Supplied accessories
Operating Instructions
Quick Setup Guide
FM wire antenna (aerial) (1)
AM loop antenna (aerial) (1)
9 kHz step
531 kHz –
Remote control (RM-AAU130) (1)
1,710 kHz
531 kHz –
1,602 kHz
R6 (size AA) batteries (2)
Design and specifi cations are subject to
change without notice.
Halogenated fl ame retardants are not used in
the certain printed wiring boards.
FM STEREO / FM-AM RECEIVER
US Model
AEP Model

Advertisement

Table of Contents
loading

Related Manuals for Sony STR-DH130

Summary of Contents for Sony STR-DH130

  • Page 1 Analog (Except PORTABLE IN) Sensitivity: 500 mV/ 50 kilohms : 96 dB (A, 500 mV Outputs Analog (AUDIO OUT) Voltage: 500 mV/ 10 kilohms FM STEREO / FM-AM RECEIVER 9-890-596-01 Sony Corporation 2012A08-1 © 2012.01 Published by Sony EMCS (Malaysia) PG Tec...
  • Page 2 WHOSE PART NUMBERS APPEAR AS SHOWN IN THIS TIONNEMENT. NE REMPLACER CES COM- POSANTS QUE MANUAL OR IN SUPPLEMENTS PUBLISHED BY SONY. PAR DES PIÈCES SONY DONT LES NUMÉROS SONT DON- NÉS DANS CE MANUEL OU DANS LES SUPPLÉMENTS PUBLIÉS PAR SONY.

  • Page 3: Table Of Contents

    STR-DH130 TABLE OF CONTENTS 1. DISASSEMBLY 1-1. Case ..................4 1-2. Back Panel Section ............. 5 1-3. Front Panel Section ............. 5 1-4. MAIN Board Section ............6 2. TEST MODE ..............7 3. FM TUNER CHECK ............9 4. DIAGRAMS 4-1.

  • Page 4: Disassembly

    STR-DH130 SECTION 1 DISASSEMBLY Note: This set can be disassemble according to the following sequence. 1-1. CASE (Page 4) 1-2. BACK PANEL SECTION (Page 5) 1-3. FRONT PANEL SECTION (Page 5) 1-4. MAIN BOARD SECTION (Page 6) Note: Follow the disassembly procedure in the numerical order given.

  • Page 5: Back Panel Section

    STR-DH130 1-2. BACK PANEL SECTION 5 seven screws (+BVTP 3x8) 4 two screws (+BVTP 3x8) CNP901 (3P) 3 three screws (+BVTP 3x8) wire (flat type) (9 core) (CNS402) 1-3. FRONT PANEL SECTION CNP790 (4P) front panel section wire (flat type) (15 core)

  • Page 6: Main Board Section

    STR-DH130 1-4. MAIN BOARD SECTION CNP911 (5P) CNP902 (2P) 4 one screws CNP930 (5P) 5 two screws (+BVTP 3x8) (+BVTP 3x8) 6 two screws (+BVTP 3x8) MAIN board section...

  • Page 7: Test Mode

    STR-DH130 SECTION 2 TEST MODE 3. Turn the [INPUT SELECTOR] control, confi rm display. [AM CHANNEL STEP 9 kHz/10 kHz SELECTION MODE] (US, Canadian model only) * Either the 9 kHz step or 10 kHz step can be selected for the AM...
  • Page 8 STR-DH130 [DESTINATION WRITE MODE] * Write the set destination when the destination is “UNKNOWN”. This mode can be performed once only. * Procedure: 1. Press the [ ] button to turn on the main power. 2. Press the [FM MODE] and [DISPLAY] buttons simultaneously.

  • Page 9: Fm Tuner Check

    STR-DH130 SECTION 3 FM TUNER CHECK FM AUTO STOP CHECK generator OUT (75 Ω) Procedure: 1. Turn on the set. 2. Input the following signal from Signal Generator to FM antenna input directly. * Carrier Frequency: A=87.5 MHz, B=98 MHz, C=108 MHz...

  • Page 10: Diagrams

    STR-DH130 SECTION 4 DIAGRAMS • Circuit Boards Location THERMAL board (for US and Canadian model only) TUNER1 board POWER KEY board HEADPHONE board MAIN board DISPLAY board...

  • Page 11: Block Diagram - Main Section

    STR-DH130 4-1. BLOCK DIAGRAM — MAIN SECTION — INPUT SELECTOR IC400 POWER AMP J404 IC700 INR9 BOOSTER INL9 +V OUT1 PORTABLE IN Q703 TB401 LIMITER OUTPUT L Q701, Q702 J401 BOOSTER -V OUT1 Q704 INL7 SA-CD/CD RY350 AUDIO IN OVERLAND...

  • Page 12: Block Diagram - Display And Power Section

    STR-DH130 4-2. BLOCK DIAGRAM — DISPLAY AND POWER SECTION — F910 DC-DC RECTIFIER FL101 REGULATOR CONVERTER Q001 D910-913 TOOL IC606 F920 +12V DC 32-42 14-29,31 RECTIFIER D920-923 GRID 1-11 SEG 1-17 F921 FL_DATA FL_CLK REGULATOR FL_LAT (VDD) IC701 FL DRIVER...
  • Page 13 STR-DH130 • Waveforms THIS NOTE IS COMMON FOR PRINTED WIRING BOARDS AND SCHEMATIC DIAGRAMS. (In addition to this, the necessary note is printed in each block.) – MAIN Board – For Printed Wiring Boards. For Schematic Diagrams. Note: Note: IC702 qd (X313(XOUT)) •...

  • Page 14: Printed Wiring Board - Main Board

    STR-DH130 4-3. PRINTED WIRING BOARD — MAIN BOARD — • Refer to page 10 for Circuit Boards Location. : Uses unleaded solder. MAIN BOARD SPEAKERS IMPEDANCE USE 8-16 POWER TRANSTORMER T901 SA-CD/CD MD/TAPE BD/DVD VIDEO PORTABLE AUDIO AUDIO AUDIO AUDIO...

  • Page 15: Schematic Diagram - Main Board 1/3

    STR-DH130 • See page 13 for Waveforms. • See page 24 for IC Pin Function Descriptions. 4-4. SCHEMATIC DIAGRAM — MAIN BOARD 1/3 — • Refer to page 21 IC Block Diagrams. C630 MAIN BOARD (1/3) 0.047 IC602 IC602 S-80929CNMC-G8ZT2G...

  • Page 16: Schematic Diagram - Main Board 2/3

    STR-DH130 4-5. SCHEMATIC DIAGRAM — MAIN BOARD 2/3 • Refer to page 21 IC Block Diagrams. MAIN BOARD (2/3) Q711,Q712 Q761,Q762 CURRENT DETECTOR R778 [FR] R744 R781 C781 D751 R782 C761 DA2J10100L 0.01 100k R761 L778 C742 R742 220p R743 4.7k...

  • Page 17: Schematic Diagram - Main Board 3/3

    STR-DH130 4-6. SCHEMATIC DIAGRAM — MAIN BOARD 3/3 • Refer to page 21 IC Block Diagrams. MAIN BOARD (3/3) D910 F910 1SR154-400TE-25 250V CL931 IC606 C910 D911 0.47 C912 1SR154-400TE-25 IC606 3300 1SR154-400TE-25 IC604 IC604 BA50BC0FP-E2 D912 C911 BA33BC0FP-E2 +5V REG 0.47...

  • Page 18: Printed Wiring Board - Display And Power Key Board

    STR-DH130 4-7. PRINTED WIRING BOARD — DISPLAY AND POWER KEY BOARD — • Refer to page 10 for Circuit Boards Location. DISPLAY BOARD MAIN BOARD CL238 CNS600 CNS101 FL101 (Page 14) R199 CL239 CL240 R198 LP102 CL235 RV102 CL232 R124...

  • Page 19: Schematic Diagram - Display And Power Key Board

    STR-DH130 4-8. SCHEMATIC DIAGRAM — DISPLAY AND POWER KEY BOARD — • Refer to page 21 IC Block Diagrams. DISPLAY BOARD FL101 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 27 28 29 30 31 32 33 34 35 36 37 38 39 40 41 42 43 44 45 46 47 48 49 50...

  • Page 20: Printed Wiring Board - Headphone, Thermal And Tuner1 Board

    STR-DH130 4-9. PRINTED WIRING BOARD — HEADPHONE, THERMAL AND TUNER1 BOARD — 4-10. SCHEMATIC DIAGRAM — HEADPHONE, THERMAL AND TUNER1 BOARD — : Uses unleaded solder. • Refer to page 21 IC Block Diagrams. • Refer to page 10 for Circuit Boards Location.

  • Page 21: Ic Block Diagrams

    STR-DH130 • IC Block Diagrams IC100 PT6315 (DISPLAY BOARD) Grid driver Multiplexed driver GRID10 Command decoder GRID11 Display memory SEG17 24 bits x 12 words Timing generator key scan DOUT SEG16 Key data memory Serial SEG15 (2 x 16 bits)
  • Page 22 STR-DH130 IC400 BD3474KS2 (MAIN BOARD (1/3)) INR2 FRIN2 INL2 FLIN2 INR1 INL1 SRIN2 SLIN2 SWIN2 SUB1L Mode Mode Mode SUB1R CIN2 Selector Selector Selector RECL5 RECR5 ADCR ADCL RECL1 RECR1 FRIN1 FLIN1 RECL2 SRIN1 RECR2 RECL3 SLIN1 Volume Volume Volume...
  • Page 23 STR-DH130 IC101 RZ5B801-0001E2 (TUNER1 Board) (US, CND) IISD IISD VDDRF FM Antenna Digital Signal Process LOUT Filter Digital Stereo FRF1 Mixer Demodulator Decoder FM LNA ROUT Digital Demodulator LRCK GNDRF LRCK / LOUT Image Station BCLK LRCK Control Detector Generator...
  • Page 24 STR-DH130 • IC Pin Function Descriptions MAIN BOARD (1/3) IC702 R5F364AEDFA Pin No. Pin Name Description FL_DATA Serial data signal output to FL Driver, PT6315 FL_CLK Serial clock signal output to FL Driver, PT6315 FL_LAT Serial data latch signal output to FL Driver, PT6315 (H: Inactive, L: Active)
  • Page 25 STR-DH130 Pin No. Pin Name Description NO-USE NO-USE NO-USE NO-USE NO-USE NO-USE NO-USE NO-USE NO-USE NO-USE NO-USE NO-USE NO-USE NO-USE NO-USE NO-USE — Vcc2 Power supply terminal (+3.3V) NO-USE NO-USE — Ground terminal AD_1 Key input terminal (A/D input) AD_0...

  • Page 26: Exploded Views

    STR-DH130 SECTION 5 EXPLODED VIEWS Note: • The mechanical parts with no reference The components identifi ed by mark 0 • -XX and -X mean standardized parts, so number in the exploded views are not sup- or dotted line with mark 0 are critical for they may have some difference from the plied.

  • Page 27: Front Panel Section

    STR-DH130 5-2. FRONT PANEL SECTION not supplied (POWER KEY board) not supplied (HEADPHONE SUPPORT board) RV101 not supplied (HEADPHONE board) FL101 RV102 supplied with RV101 supplied with RV102 Ref. No. Part No. Description Remark Ref. No. Part No. Description Remark...

  • Page 28: Back Panel Section

    STR-DH130 5-3. BACK PANEL SECTION not supplied not supplied not supplied ( TUNER1 board ) Ref. No. Part No. Description Remark 1-828-310-61 WIRE (FLAT TYPE) (9 CORE) 4-966-267-12 BUSHING (FBS001), CORD 0 103 1-777-071-83 CORD, POWER (AEP) 0 103 1-837-308-11...

  • Page 29: Chassis Section

    STR-DH130 5-4. CHASSIS SECTION not supplied (Thermal board) supplied with Q704, Q703, Q754, Q753 Q704 Q703 Q754 Q753 T901 F901 Ref. No. Part No. Description Remark Ref. No. Part No. Description Remark A-1847-542-A MAIN BOARD, COMPLETE (US) 0 F901 1-532-464-33 FUSE, T2.5AL 250V (AEP)

  • Page 30: Electrical Parts List

    STR-DH130 SECTION 6 DISPLAY ELECTRICAL PARTS LIST Note: • Due to standardization, replacements in • CAPACITORS When indicating parts by reference num- the parts list may be different from the uF: μF ber, please include the board name. parts specifi ed in the diagrams or the com- •...
  • Page 31 STR-DH130 HEADPHONE MAIN Ref. No. Part No. Description Remark Ref. No. Part No. Description Remark HEADPHONE BOARD C633 1-114-868-11 CERAMIC CHIP 0.1uF ***************** C634 1-114-868-11 CERAMIC CHIP 0.1uF C635 1-162-964-11 CERAMIC CHIP 0.001uF < CAPACITOR > C636 1-135-372-31 ELECT 470uF...
  • Page 32 STR-DH130 MAIN Ref. No. Part No. Description Remark Ref. No. Part No. Description Remark CC05 1-162-927-11 CERAMIC CHIP 100PF < FERRITE BEAD > CC06 1-162-927-11 CERAMIC CHIP 100PF CC07 1-162-927-11 CERAMIC CHIP 100PF FB600 1-400-862-11 BEAD, FERRITE CC09 1-162-927-11 CERAMIC CHIP 100PF...
  • Page 33 STR-DH130 MAIN Ref. No. Part No. Description Remark Ref. No. Part No. Description Remark R350 1-216-825-11 METAL CHIP 2.2K 1/10W R635 1-216-809-11 METAL CHIP 1/10W R351 1-249-381-11 CARBON 1/4W R641 1-216-833-11 METAL CHIP 1/10W R353 1-216-841-11 METAL CHIP 1/10W R643...
  • Page 34 STR-DH130 MAIN POWER KEY THERMAL TUNER1 Ref. No. Part No. Description Remark Ref. No. Part No. Description Remark R756 1-216-825-11 METAL CHIP 2.2K 1/10W < RESISTOR > R757 1-216-844-11 METAL CHIP 1/10W R133 1-216-819-11 METAL CHIP 1/10W R758 1-216-818-11 METAL CHIP...
  • Page 35 STR-DH130 TUNER1 Ref. No. Part No. Description Remark Ref. No. Part No. Description Remark < JUMPER RESISTOR > ACCESSORIES ************ JR101 1-216-864-11 SHORT CHIP JR102 1-216-296-11 SHORT CHIP 1-490-078-11 REMOTE COMMANDER (RM-AAU130) JR105 1-216-296-11 SHORT CHIP (including BATERY LID) JR106...
  • Page 36 STR-DH130 REVISION HISTORY Checking the version allows you to jump to the revised page. Also, clicking the version at the top of the revised page allows you to jump to the next revised page. Ver. Date Description of Revision 2012.01...

Table of Contents