Sony HCD-S500 Service Manual
Compact av system
Hide thumbs
Also See for HCD-S500:
- Operating instructions manual (84 pages) ,
- Service manual (100 pages) ,
- Service manual (108 pages)
Advertisement
SERVICE MANUAL
Ver 1.6 2003. 07
HCD-S500/S800 are the amplifier, DVD/CD and
tuner section in DAV-S500/S800.
AUDIO POWER SPECIFICATIONS
POWER OUTPUT AND TOTAL HARMONIC DISTORTION:
With 6 ohm loads, both channels driven, from 120 – 10,000 Hz; rated
40 watts per channel minimum RMS power, with no more than 10 %
total harmonic distortion from 250 milliwatts to rated output.
Amplifier section
S500 MODEL
Stereo mode
40 W + 40 W (6 ohms at 1 kHz, THD 10 %)
Surround mode
Front: 40 W + 40 W
Center*: 40 W
Rear*: 40 W + 40 W (6 ohms at 1 kHz, THD 10 %)
Subwoofer*: 80 W (3 ohms at 100 Hz, THD 10 %)
S800 MODEL
Stereo mode
50 W + 50 W (6 ohms at 1 kHz, THD 10 %)
Surround mode
Front: 50 W + 50 W
Center*: 50 W
Rear*: 50 W + 50 W (6 ohms at 1 kHz, THD 10 %)
Subwoofer*: 100 W (3 ohms at 100 Hz, THD 10 %)
* Depending on the sound field settings and the source, there may be no sound output.
Inputs (Analog)
VIDEO 1, 2:
Sensitivity: 150 mV
Impedance: 50 kilohms
Inputs (Digital)
VIDEO 2 (optical):
Sensitivity: –
Outputs (Analog)
VIDEO 1 (AUDIO OUT):
Voltage: 2 V
Impedance: 1 kilohms
PHONES:
Accepts low- and high-impedance headphones
Outputs (Digital)
DIGITAL OUT (CD)
Sensitivity: –
SACD/DVD system
Laser
Semiconductor laser
Signal format system
NTSC or NTSC/PAL
Frequency response (at 2 CH STEREO mode)
DVD (PCM): 2 Hz to 22 kHz (±1.0 dB)
CD: 2 Hz to 20 kHz (±1.0 dB)
Signal-to-noise ratio
More than 80 dB (VIDEO 1 (AUDIO) connectors only)
Harmonic distortion
Less than 0.03 %
FM tuner section
System
PLL quartz-locked digital synthesizer system
Tuming range:
US, Canadian models:
Tuming range:
87.5
–
108.0 MHz (100 kHz step)
Tuming range:
Other
Tuming range:
87.5 – 108.0 MHz (50 kHz step)
Antenna
FM wire antenna
Antenna terminals
75 ohms, unbalanced
Intermediate frequency
10.7 MHz
Sony Corporation
9-873-291-07
2003G16-1
Home Audio Company
© 2003.07
Published by Sony Engineering Corporation
HCD-S500/S800
Photo : HCD-S500
SPECIFICATIONS
Australian Model
Model Name Using Similar Mechanism
Mechanism Type
Base Unit Name
Optical Pick-up Name
AM tuner section
System
Tuner section:
PLL quartz-locked digital synthesizer system
Tuning range
US, Canadian models:
530
– 1,710 kHz (with the interval set at 10 kHz)
531 – 1,710 kHz (with the interval set at 9 kHz)
AEP, UK, Saudi Arabia models:
531 – 1,602 kHz (with the interval set at 9 kHz)
Other models:
531 – 1,602 kHz (with the interval set at 9 kHz)
530 – 1,710 kHz (with the interval set at 10 kHz)
Antenna
Loop antenna
Video section
Inputs
Video: 1 Vp-p 75 ohms
Outputs
Video: 1 Vp-p 75 ohms
S-video:
Y: 1 Vp-p 75 ohms
C: 0.286 Vp-p 75 ohms
General
Power requirements
US, Canadian models:
120 V AC, 60 Hz
AEP, UK models:
220 – 240 V AC, 50/60 Hz
Australian and E models:
220 – 240 V AC, 50/60 Hz
Mexican model:
120 V AC, 60 Hz
Other models:
110 – 240 V/220 – 240 V AC, 50/60 Hz
Power consumption
98 W (120 V AC) 98 W (230 V AC)
355 × 70 × 378 mm (14 × 2
Dimensions (approx.)
Mass (approx.)
4.0 kg (9 lb 8 oz)
Operating temperature
5
˚
C to 35
˚
C (41
˚
F to 95
Operating humidity
5 % to 90 %
Supplied accessories
Check that you have the following items:
•
Speakers (5)
•
Subwoofer (1)
•
AM loop antenna (1)
•
FM wire antenna (1)
Speaker cords (5m × 4, 15m × 2) (16ft. × 4, 49ft. × 2)
•
•
Video cord (1)
•
Remote commander (remote) RM-SS800 (1)
•
R6 (size AA) batteries (2)
•
Foot pads (15)
•
Speakers-connection and Installation (card) (1)
•
Quick reference for Remote commander (card) (1)
Design and specifications are subject to change without notice.
COMPACT AV SYSTEM
US Model
Canadian Model
HCD-S500
AEP Model
UK Model
E Model
HCD-S500/S800
NEW
CDM-55D-DVBU8
DVBU8
KHM-240AAA
× 15 inches) (w/h/d) incl. projecting parts
7
/
8
˚
F)
Advertisement
Table of Contents
Related Manuals for Sony HCD-S500
Summary of Contents for Sony HCD-S500
-
Page 1: Specifications
Ver 1.6 2003. 07 HCD-S500 AEP Model UK Model E Model Australian Model HCD-S500/S800 Photo : HCD-S500 HCD-S500/S800 are the amplifier, DVD/CD and tuner section in DAV-S500/S800. Model Name Using Similar Mechanism Mechanism Type CDM-55D-DVBU8 Base Unit Name DVBU8 Optical Pick-up Name... - Page 2 HCD-S500/S800 WAVEFORMS THIS NOTE IS COMMON FOR PRINTED WIRING – RF-240 BOARD – – DVD BOARD – – AMP BOARD – – I/O BOARD – BOARDS AND SCHEMATIC DIAGRAMS. (In addition to this, the necessary note is printed in each block.) 3.5Vp-p...
- Page 3 HCD-S500/S800 6-1. BLOCK DIAGRAMS – RF/SERVO, VIDEO SECTION – OPTICAL PICK-UP (KHM-240 AAA/J1RP) IC503 IC001 AV DECODER IC302 DVD/CD RF AMP IC700 SERVO DSP DIGITAL SERVO J600 (1/4) INPUT SEL HD8-15 RF IN SIGO RFIN1 DVD/CD VIDEO IN D0-7 IC701...
-
Page 4: Cpu Section
HCD-S500/S800 – CPU SECTION – IC600 INPUT SEL J600 (3/4) IC603 AUDIO IN L VIDEO1 IC606 AUDIO IN L DIGITAL AUDIO VIDEO2 10 9 I/F RECEIVER IC602 IC603 OPTICAL DIGITAL OUT DIGITAL IN DIN1 SPDIF 1 IN OPTICAL Q603 Q604... -
Page 5: Power Section
HCD-S500/S800 – POWER SECTION – IC305 IC301 J401 (1/2) STREAM PROCESSOR POWER DRIVER (F) L401,C451 DATA OUTL1+ OUTA OUTL2+ FRONT L401,C452 OUTB OUTR1+ R-CH L402,C453 R-CH DIAG OUTR2+ AUDIO-1 XFS1 L402,C454 REAR SECTION BCKO LRCKO LRCK RY301 +27V SCDT IC401... -
Page 6: Schematic Diagram - Rf Section
HCD-S500/S800 6-3. SCHEMATIC DIAGRAM – RF SECTION – • See page 25 for Wavefoms. • See page 58 for IC Block Diagrams. IC B/D... - Page 7 HCD-S500/S800 6-6. SCHEMATIC DIAGRAM – DVD (1/8) SECTION – • See page 25 for Wavefoms. • See page 56 for IC Block Diagrams. IC B/D...
- Page 8 HCD-S500/S800 6-7. SCHEMATIC DIAGRAM – DVD (2/8) SECTION – • See page 25 for Wavefoms. IC B/D...
- Page 9 HCD-S500/S800 6-8. SCHEMATIC DIAGRAM – DVD (3/8) SECTION –...
- Page 10 HCD-S500/S800 6-9. SCHEMATIC DIAGRAM – DVD (4/8) SECTION –...
- Page 11 HCD-S500/S800 6-10. SCHEMATIC DIAGRAM – DVD (5/8) SECTION – • See page 67 for IC Pin Function Description.
- Page 12 HCD-S500/S800 6-11. SCHEMATIC DIAGRAM – DVD (6/8) SECTION – • See page 62 for IC Pin Function Description.
- Page 13 HCD-S500/S800 6-12. SCHEMATIC DIAGRAM – DVD (7/8) SECTION –...
- Page 14 HCD-S500/S800 6-13. SCHEMATIC DIAGRAM – DVD (8/8) SECTION – • See page 25 for Wavefoms. • See page 56 for IC Block Diagrams. • See page 60 for IC Pin Function Description. IC B/D...
-
Page 15: Schematic Diagram - Amp Section
HCD-S500/S800 Ver 1.1 2002.01 6-16. SCHEMATIC DIAGRAM – AMP SECTION (1/2) – S500:US,CND,AEP, S500:US,CND,AEP, CIS,UK,MX,KR/S800 CIS,UK,MX,KR/S800 S500:US,CND,AEP,CIS,UK,MX,KR/S800 S500:US,CND,AEP, CIS,UK,MX,KR/S800 S500:US,CND,AEP,CIS, UK,MX,KR/S800 S500:US,CND,AEP, CIS,UK,MX,KR/S800 S500:US,CND,AEP, CIS,UK,MX,KR/S800 0.1 : S500/US,CND,AEP,CIS,UK,MX,KR,S800 0.01 : EXCEPT S500/US,CND,AEP,CIS,UK,MX,KR,S800 10p : EXCEPT S500/US,CND,AEP,CIS,UK,MX,KR,S800 47p : S500/US,CND,AEP,CIS,UK,MX,KR,S800 1uH : S500/US,CND,AEP,CIS,UK,MX,KR,S800... - Page 16 HCD-S500/S800 6-17. SCHEMATIC DIAGRAM – AMP SECTION (2/2) – • See page 25 for Wavefoms. 0.1 : S500/US,CND,AEP,CIS,UK,MX,KR,S800 0.01 : EXCEPT S500/US,CND,AEP,CIS,UK,MX,KR,S800 S500 : US,CND,AEP,CIS,UK,MX,KR,S800 100/10V : S500/US,CND,AEP,CIS,UK,MX,KR,S800 0.1/50V : EXCEPT S500/US,CND,AEP,CIS,UK,MX,KR,S800 0.1/16V : S500/US,CND,AEP,CIS,UK,MX,KR,S800 0.01/25V : EXCEPT S500/US,CND,AEP,CIS,UK,MX,KR,S800 100/35V : S500/US,CND,AEP,CIS,UK,MX,KR,S800...
-
Page 17: Schematic Diagram - I/O Section
HCD-S500/S800 6-19. SCHEMATIC DIAGRAM – I/O SECTION (1/2) – • See page 57 for IC Block Diagrams. CIS, IC B/D IC B/D EXCEPT S500:AEP,UK... - Page 18 HCD-S500/S800 6-20. SCHEMATIC DIAGRAM – I/O SECTION (2/2) – • See page 25 for Wavefoms.
-
Page 19: Schematic Diagram - Panel Section
HCD-S500/S800 Ver 1.3 2002.07 6-22. SCHEMATIC DIAGRAM – PANEL SECTION – • See page 57 for IC Block Diagrams. IC B/D MA111-TX MA111-TX MA111-TX MA111-TX D810 UDZSTE-176.2B... -
Page 20: Schematic Diagram - Power Section
HCD-S500/S800 Ver 1.4 2002.11 6-27. SCHEMATIC DIAGRAM – POWER SECTION – • See page 59 for IC Block Diagrams. FMB-G14L IC B/D IC907 820/200V 390/450V...