Sony CDX-F5700 Service Manual
Fm/am compact disc player
Hide thumbs
Also See for CDX-F5700:
- Operating insructions (172 pages) ,
- Operating instructions manual (92 pages) ,
- Service manual (52 pages)
Table of Contents
Advertisement
CDX-F5700/F5700X/FW570
SERVICE MANUAL
Ver 1.0 2004. 02
• The tuner and CD sections have no adjustments.
AUDIO POWER SPECIFICATIONS (US MODEL)
POWER OUTPUT AND TOTAL HARMONIC DISTORTION
23.2 watts per channel minimum continuous average power into
4 ohms, 4 channels driven from 20 Hz to 20 kHz with no more
than 5% total harmonic distortion.
CD player section
Signal-to-noise ratio
120 dB
Frequency response
10 – 20,000 Hz
Wow and flutter
Below measurable limit
Tuner section
FM
Tuning range
US, Canadian Model:
87.5 – 107.9 MHz
E Model:
FM tuning interval:
50 kHz/200 kHz
switchable
87.5 – 108 MHz (at 50 kHz step)
87.5 – 107.9 MHz (at 200 kHz step)
Antenna terminal
External antenna connector
Intermediate frequency 10.7 MHz/450 kHz
Usable sensitivity
9 dBf
Selectivity
75 dB at 400 kHz
Signal-to-noise ratio
67 dB (stereo),
69 dB (mono)
Harmonic distortion at 1 kHz
0.5% (stereo),
0.3% (mono)
Separation
35 dB at 1 kHz
Frequency response
30 – 15,000 Hz
Sony Corporation
9-877-605-01
2004B04-1
e Vehicle Company
© 2004. 02
Published by Sony Engineering Corporation
Photo: CDX-F5700
Model Name Using Similar Mechanism
CD Drive Mechanism Type
Optical Pick-up Name
SPECIFICATIONS
AM
Tuning range
Antenna terminal
Intermediate frequency 10.7 MHz/450 kHz
Sensitivity
Power amplifier section
Outputs
Speaker impedance
Maximum power output 52 W × 4 (at 4 ohms)
General
Outputs
Inputs
FM/AM COMPACT DISC PLAYER
US Model
CDX-F5700/FW570
Canadian Model
E Model
NEW
MG-611MA-186//Q
KSS1000E
US, Canadian Model:
530 – 1,710 kHz
E Model:
AM tuning interval:
9 kHz/10 kHz switchable
531 – 1,602 kHz (at 9 kHz step)
530 – 1,710 kHz (at 10 kHz step)
External antenna connector
30 µV
Speaker outputs
(sure seal connectors)
4 – 8 ohms
Audio outputs terminal (front/rear)
Subwoofer output terminal (mono)
Power antenna relay control terminal
Power amplifier control terminal
Telephone ATT control terminal
Illumination control terminal
BUS control input terminal
BUS audio input or AUX IN terminal
Remote controller input terminal
Antenna input terminal
– Continued on next page –
CDX-F5700
CDX-F5700X
1
Advertisement
Table of Contents
Related Manuals for Sony CDX-F5700
Summary of Contents for Sony CDX-F5700
- Page 1 30 – 15,000 Hz BUS audio input or AUX IN terminal Remote controller input terminal Antenna input terminal – Continued on next page – FM/AM COMPACT DISC PLAYER Sony Corporation 9-877-605-01 2004B04-1 e Vehicle Company © 2004. 02 Published by Sony Engineering Corporation...
- Page 2 Parts for installation and connections (1 set) Front panel case (1) Card remote commander RM-X114 Note This unit cannot be connected to a digital preamplifier or an equalizer which is Sony BUS system compatible. Design and specifications are subject to change without notice.
- Page 3 CDX-F5700/F5700X/FW570 Notes on CD-Rs (recordable CDs)/CD-RWs (rewritable UNLEADED SOLDER CDs) Boards requiring use of unleaded solder are printed with the lead This unit can play the following discs: free mark (LF) indicating the solder contains no lead. (Caution: Some printed circuit boards may not come printed with the lead free mark due to their particular size.)
-
Page 4: Table Of Contents
CDX-F5700/F5700X/FW570 TABLE OF CONTENTS 1. GENERAL Location of Controls (US, Canadian Model) ......5 Location of Controls (E Model) ..........5 Connections (US, Canadian Model) ........6 Connections (E Model) ............7 2. DISASSEMBLY 2-1. Sub Panel Assy ..............9 2-2. -
Page 5: General
CDX-F5700/F5700X/FW570 SECTION 1 GENERAL This section is extracted from instruction manual. (US, Canadian Model) (E Model) -
Page 6: Connections (Us, Canadian Model)
CDX-F5700/F5700X/FW570 Connections (US, Canadian Model) -
Page 7: Connections (E Model)
CDX-F5700/F5700X/FW570 Connections (E Model) -
Page 8: Disassembly
CDX-F5700/F5700X/FW570 SECTION 2 DISASSEMBLY Note : This set can be disassemble according to the following sequence. 2-1. SUB PANEL ASSY (Page 9) 2-2. CD MECHANISM BLOCK (Page 9) 2-10. SERVO BOARD 2-3. MAIN BOARD 2-4. CHASSIS (T) SUB ASSY (Page 13) -
Page 9: Sub Panel Assy
CDX-F5700/F5700X/FW570 Note : Follow the disassembly procedure in the numerical order given. 2-1. SUB PANEL ASSY 3 two claws 2 two claws CN370 1 two screws (+PTT 2.6 x 6) 5 sub panel assy 2-2. CD MECHANISM BLOCK 7 bracket (CD) -
Page 10: Main Board
CDX-F5700/F5700X/FW570 2-3. MAIN BOARD 5 screw 1 three ground point screws (+PTT 2.6 x 6) (+PTT 2.6 x 6) 4 CN410 cord (RCA) 2 two screws 3 MAIN board (+PTT 2.6 x 6) insulating sheet 2-4. CHASSIS (T) SUB ASSY... -
Page 11: Roller Arm Assy
CDX-F5700/F5700X/FW570 2-5. ROLLER ARM ASSY 3 washer 5 roller arm assy 4 worm wheel (RA) 2 spring (RAR) 1 spring (RAL) 2-6. CHASSIS (OP) ASSY qa chassis (OP) assy 0 coil spring (damper) lever (D) 4 washer 1 CN1 9 two coil springs (damper) -
Page 12: Optical Pick-Up
CDX-F5700/F5700X/FW570 2-7. OPTICAL PICK-UP 2 chucking arm sub assy 5 claw 1 tension coil spring (CHKG) 7 optical pick-up 6 main shaft 4 rack (SL) 3 screw (+B 1.4 x 5) 2-8. SL MOTOR ASSY (M902) 1 screw (+P 1.4 x 1.8) -
Page 13: Le Motor Assy (M903)
CDX-F5700/F5700X/FW570 2-9. LE MOTOR ASSY (M903) 8 screw 0 woam (LEB) assy (+M 1.7 x 2.5) 9 bearing (LEB) 2 washer qa screw (+M 1.7 x 2.5) qf two toothed lock screws 3 gear (LE1) (+M 1.4 ) lever (D) -
Page 14: Diagrams
CDX-F5700/F5700X/FW570 SECTION 3 DIAGRAMS 3-1. IC PIN DESCRIPTIONS • IC3 CXD3059BR (DIGITAL SERVO/DIGITAL SIGNAL PROCESSOR) (SERVO BOARD (1/2)) Pin No. Pin Name Pin Description MIRR Mirrer signal input/output DFCT Defect signal input/output Focus OK signal input/output — Ground pin LOCK Not used in this set. - Page 15 CDX-F5700/F5700X/FW570 Pin No. Pin Name Pin Description CLTV VCO1 control voltage input FILO Filter signal output for master PLL FILI Filter signal input for master PLL Charge pump output for master PLL AVDD5 — Analog power supply pin DDVROUT DC/DC converter output...
- Page 16 CDX-F5700/F5700X/FW570 Pin No. Pin Name Pin Description XLAT Latch signal input CLOK Serial data transfer clock signal input — Digital power supply pin for internal SENS SENS signal output SCLK Clock signal input for SENS serial data read out ATSK...
- Page 17 Power supply pin for D/A output converter (+3.3 V) Not used in this set. (Open) DAVSS — Ground pin for D/A output converter UNISO SONY-BUS data signal output UNISI SONY-BUS data signal input UNICKO SONY-BUS clock signal output 7, 8...
- Page 18 CDX-F5700/F5700X/FW570 Pin No. Pin Name Pin Description E2P SIO Serial data signal input/output for EEPROM communication DOORIND Sub panel power supply control signal output AMPSTB Power regulator IC standby signal output Not used in this set. (Open) LCDSO Serial data signal output to the LCD driver Flash: UART serial output...
-
Page 19: Block Diagram -Cd Section
CDX-F5700/F5700X/FW570 3-2. BLOCK DIAGRAM — CD SECTION — • R-ch is omitted due to same as L-ch. • Siganal Path : CD PLAY DETECTOR MAIN RFACO 42 RFACI ASYO 45 ASYI AOUT1 CD-L SECTION (Page 20) AOUT2 R-CH RF AMP,DIGITAL SERVO,... -
Page 20: Block Diagram -Main Section
CDX-F5700/F5700X/FW570 3-3. BLOCK DIAGRAM — MAIN SECTION — SOUND CONTROL, ELECTRONIC VOLUME IC351 J451(2/2) OUTLR AUDIO OUT REAR MUTE R-CH J451(1/2) Q452 4 IN1L+ OUTLF AUDIO OUT R-CH 7 IN1R+ FRONT MUTE R-CH 5 IN1- AUDIO IN Q440 CN410 R-CH... -
Page 21: Block Diagram -Display Section
CDX-F5700/F5700X/FW570 3-4. BLOCK DIAGRAM — DISPLAY SECTION — 3-5. CIRCUIT BOARDS LOCATION SYSTEM CONTROL LCD DRIVER SERVO board IC600 (3/3) IC901 SENSOR board SEG01 ROTARY RE 0 SEG16 LCD901 ENCODER • S921 (1/2) 8 RE 1 SEG17 LIQUID LCD SO... -
Page 22: Note For Printed Wiring Boards And Schematic Diagrams
CDX-F5700/F5700X/FW570 3-6. NOTE FOR PRINTED WIRING BOARDS AND SCHEMATIC DIAGRAMS 3-7. WAVEFORMS THIS NOTE IS COMMON FOR PRINTED WIRING — Servo Board — BOARDS AND SCHEMATIC DIAGRAMS. — Main Board — (MODE: CD PLAY) (In addition to this, the necessary note is printed in each block.) -
Page 23: Printed Wiring Boards -Cd Mechanism Section
CDX-F5700/F5700X/FW570 3-8. PRINTED WIRING BOARDS — CD MECHANISM SECTION — • Refer to page 21 for Circuit Boards Location. : Uses unleaded solder. (Page 28) • Semiconductor Location Ref. No. Location C-10... -
Page 24: Schematic Diagram -Cd Mechanism Section (1/2)
CDX-F5700/F5700X/FW570 3-9. SCHEMATIC DIAGRAM — CD MECHANISM SECTION (1/2) — • Refer to page 22 for Waveforms. TP59 TP60 TP57 TP61 TP180 TP181 TP129 TP72 TP123 TP128 TP139 TP53 TP140 TP56 TP55 TP167 TP54 TP48 TP49 TP71 TP175 TP47 R114... -
Page 25: Schematic Diagram -Cd Mechanism Section (2/2)
CDX-F5700/F5700X/FW570 • Refer to page 22 for Waveform. 3-10. SCHEMATIC DIAGRAM — CD MECHANISM SECTION (2/2) — • Refer to page 32 for IC Block Diagrams. (Page 24) R136 R146 R117 IC B/D TP11 TP12 R140 TP19 TP20 TP17 M903... -
Page 26: Schematic Diagram -Main Section (1/2)
CDX-F5700/F5700X/FW570 3-11. SCHEMATIC DIAGRAM — MAIN SECTION (1/2) — • Refer to page 32 for IC Block Diagrams. C303 C302 C308 JC302 C306 J451 C301 C444 C424 C304 C305 C307 C309 C317 C423 C443 CN410 IC B/D R423 R443 C442... -
Page 27: Schematic Diagram -Main Section (2/2)
CDX-F5700/F5700X/FW570 • Refer to page 22 for Waveforms. 3-12. SCHEMATIC DIAGRAM — MAIN SECTION (2/2) — • Refer to page 33 for IC Block Diagram. (Page 26) IC501 Q501 R531 R517 C506 R542 R514 R546 (Page 24) C502 C501 S501... -
Page 28: Printed Wiring Board -Main Section
CDX-F5700/F5700X/FW570 3-13. PRINTED WIRING BOARD — MAIN SECTION — • Refer to page 21 for Circuit Boards Location. : Uses unleaded solder. (Page 23) • Semiconductor Location Ref. No. Location Ref. No. Location D702 D101 D703 D102 D704 D103 D705... -
Page 29: Printed Wiring Board -Sub Section
CDX-F5700/F5700X/FW570 3-14. PRINTED WIRING BOARD — SUB SECTION — • Refer to page 21 for Circuit Boards Location. : Uses unleaded solder. (Page 30) (Page 28) CN802 3-15. SCHEMATIC DIAGRAM — SUB SECTION — CN801 CN802 R801 LED801 D801 (Page 31) -
Page 30: Printed Wiring Board -Display Section
CDX-F5700/F5700X/FW570 3-16. PRINTED WIRING BOARD — DISPLAY SECTION — • Refer to page 21 for Circuit Boards Location. : Uses unleaded solder. (Page 29) R917 R914 R919 R916 R920 R918 R915 R912 R984 R913 R924 R923 R921 R922 R911 R965... -
Page 31: Schematic Diagram -Display Section
CDX-F5700/F5700X/FW570 3-17. SCHEMATIC DIAGRAM — DISPLAY SECTION — R971 R976 R975 R974 R973 R977 IC971 R981 R983 R985 R987 R989 R991 IC981 LED931 LED932 LED933 LED934 C973 C971 R993 R994 LED904 R986 C972 LED916 R984 LED903 LED912 LED917 C906 MENU... -
Page 32: Ic Block Diagrams
CDX-F5700/F5700X/FW570 3-18. IC BLOCK DIAGRAMS IC7 R1114N151D-TR-FA (SERVO Board (2/2)) IC1 LA6560-TE-L-E (SERVO Board (2/2)) 36 S-GND 5 VOUT THERMAL SHUTDOWN INPUT 35 VCONT VCC2 BTL-AMP MUTE 34 MUTE OUTPUT OUTPUT ON/OFF VLO- CONTROL 33 VIN4 CURRENT VREF LIMIT VLO+... - Page 33 CDX-F5700/F5700X/FW570 IC351 TDA7416 (MAIN Board (1/2)) 30 29 24 23 HIGH PASS MIXER FILTER2 SOFT STEP FADER ACOUTR SOFT STEP ACINSW FADER ACOUTSW HIGH PASS MIXER 22 OUTRF FILTER WOOFER SOFT STEP OUTRR FILTER FADER 7 BAND EQUALIXER 20 AC2INR...
-
Page 34: Exploded Views
CDX-F5700/F5700X/FW570 SECTION 4 EXPLODED VIEWS NOTE: • The mechanical parts with no reference • Color Indication of Appearance Parts The components identified by mark 0 or dotted line with mark number in the exploded views are not supplied. Example : 0 are critical for safety. -
Page 35: Front Panel Section
X-3384-284-1 PANEL ASSY (SVX), FRONT BACK X-3384-430-2 BUTTON KIT (SVX) ASSY (F5700X) X-3378-390-3 CASE (PANEL) (for FRONT PANEL) X-3384-637-1 KNOB VOL (SVX) ASSY A-3220-956-A FP-CDX-F5700//C (U) (F5700) X-3384-424-2 PANEL ASSY (SVX), FRONT (F5700) A-3220-970-A FP-CDX-F5700X//C (E) (F5700X) X-3384-428-2 PANEL ASSY (SVX), FRONT (FW570) -
Page 36: Cd Mechanism Section (1)
CDX-F5700/F5700X/FW570 4-3. CD MECHANISM SECTION (1) (MG-611MA-186//Q) not supplied (SENSOR board) not supplied not supplied Ref. No. Part No. Description Remark Ref. No. Part No. Description Remark A-3372-444-A CHASSIS (T) SUB ASSY 3-352-758-31 SCREW (M1.7), TOOTHED LOCK 3-253-729-11 SPRING (LTR), TENSION COIL... -
Page 37: Cd Mechanism Section (2)
CDX-F5700/F5700X/FW570 4-4. CD MECHANISM SECTION (2) (MG-611MA-186//Q) (including M901) M902 not supplied not supplied not supplied not supplied The components identified by Les composants identifiés par une mark 0 or dotted line with mark marque 0 sont critiques pour 0 are critical for safety. -
Page 38: Cd Mechanism Section (3)
CDX-F5700/F5700X/FW570 4-5. CD MECHANISM SECTION (3) (MG-611MA-186//Q) M903 Ref. No. Part No. Description Remark Ref. No. Part No. Description Remark 3-348-993-01 WASHER 3-259-467-11 BRACKET (LEM) 3-259-024-01 WHEEL (RA), WORM 3-345-648-91 SCREW (M1.4), TOOTHED LOCK A-3372-441-A ARM ASSY, ROLLER A-3372-450-A WORM (LEB) ASSY... -
Page 39: Cd Mechanism Section (4)
CDX-F5700/F5700X/FW570 4-6. CD MECHANISM SECTION (4) (MG-611MA-186//Q) Ref. No. Part No. Description Remark Ref. No. Part No. Description Remark 3-259-429-11 WHEEL (LE), WORM 3-899-829-01 WASHER (SLIT) 3-344-223-01 WASHER 3-259-032-01 GEAR (LE2) 3-259-470-11 GEAR (LE1) A-3337-998-A CHASSIS (M) BLOCK ASSY 3-253-755-12 LEVER (D) -
Page 40: Electrical Parts List
CDX-F5700/F5700X/FW570 SECTION 5 DISPLAY ELECTRICAL PARTS LIST NOTE: • Due to standardization, replacements in • Items marked “*” are not stocked since The components identified by mark 0 or dotted line with mark the parts list may be different from the they are seldom required for routine service. - Page 41 CDX-F5700/F5700X/FW570 DISPLAY MAIN Ref. No. Part No. Description Remark Ref. No. Part No. Description Remark R912 1-216-819-11 METAL CHIP 1/10W R976 1-216-809-11 METAL CHIP 1/10W R913 1-216-819-11 METAL CHIP 1/10W R977 1-216-803-11 METAL CHIP 1/10W R914 1-216-821-11 METAL CHIP 1/10W...
- Page 42 CDX-F5700/F5700X/FW570 MAIN Ref. No. Part No. Description Remark Ref. No. Part No. Description Remark C301 1-115-340-11 CERAMIC CHIP 0.22uF C423 1-137-194-11 FILM 0.47uF C302 1-162-970-11 CERAMIC CHIP 0.01uF C424 1-162-927-11 CERAMIC CHIP 100PF C303 1-128-551-11 ELECT 22uF C431 1-126-964-11 ELECT...
-
Page 43: Ref. No
CDX-F5700/F5700X/FW570 MAIN Ref. No. Part No. Description Remark Ref. No. Part No. Description Remark D303 8-719-200-82 DIODE 11ES2 JC102 1-216-296-11 SHORT CHIP D304 8-719-200-82 DIODE 11ES2 JC103 1-216-296-11 SHORT CHIP D305 8-719-200-82 DIODE 11ES2 JC104 1-216-296-11 SHORT CHIP D306 8-719-200-82 DIODE 11ES2... -
Page 44: Description Remark
CDX-F5700/F5700X/FW570 MAIN Ref. No. Part No. Description Remark Ref. No. Part No. Description Remark L902 1-469-844-11 INDUCTOR 2.2uH (F5700X) R360 1-216-809-11 METAL CHIP 1/10W R361 1-216-809-11 METAL CHIP 1/10W < TRANSISTOR > R362 1-216-809-11 METAL CHIP 1/10W R363 1-216-833-11 METAL CHIP... -
Page 45: Description Remark
CDX-F5700/F5700X/FW570 MAIN SENSOR SERVO Ref. No. Part No. Description Remark Ref. No. Part No. Description Remark R533 1-216-845-11 METAL CHIP 100K 1/10W SENSOR BOARD R534 1-218-871-11 METAL CHIP 0.5% 1/10W ************** R535 1-216-845-11 METAL CHIP 100K 1/10W R536 1-216-864-11 METAL CHIP 1/10W <... - Page 46 CDX-F5700/F5700X/FW570 SERVO Ref. No. Part No. Description Remark Ref. No. Part No. Description Remark 1-100-381-11 ELECT CHIP 10uF 1-208-635-11 RES-CHIP 1/16W 1-164-156-11 CERAMIC CHIP 0.1uF 1-218-971-11 RES-CHIP 1/16W 1-164-156-11 CERAMIC CHIP 0.1uF 1-218-971-11 RES-CHIP 1/16W 1-162-970-11 CERAMIC CHIP 0.01uF 1-218-965-11 RES-CHIP...
-
Page 47: M903 A-3372-443-A Motor Assy, Le (Loading)
CDX-F5700/F5700X/FW570 SERVO Ref. No. Part No. Description Remark Ref. No. Part No. Description Remark 1-218-990-11 SHORT CHIP SUB BOARD 1-218-941-81 RES-CHIP 1/16W ********** 1-218-941-81 RES-CHIP 1/16W 1-218-977-11 RES-CHIP 100K 1/16W 1-792-195-11 CABLE, FLEXIBLE FLAT (14 CORE) (CN802) 1-218-941-81 RES-CHIP 1/16W <... - Page 48 CDX-F5700/F5700X/FW570 Ref. No. Part No. Description Remark PARTS FOR INSTALLATION AND CONNECTIONS *************************************** X-3382-647-1 FRAME ASSY, FITTING X-3381-154-1 SCREW ASSY (BS4), FITTING (F5700X) 3-349-410-11 BUSHING (F5700X) 3-934-325-01 SCREW, +K (5X8) TAPPING (F5700/FW570) 3-261-758-01 COLLAR 3-246-471-01 KEY (FRAME) 1-776-207-72 CORD (WITH CONNECTOR) (POWER)
- Page 49 CDX-F5700/F5700X/FW570 MEMO...
- Page 50 CDX-F5700/F5700X/FW570 REVISION HISTORY Clicking the version allows you to jump to the revised page. Also, clicking the version at the upper on the revised page allows you to jump to the next revised page. Ver. Date Description of Revision 2004. 02...
- Page 51 www.s-manuals.com...