Related Manuals for Lang 124S
Summary of Contents for Lang 124S
-
Page 1: Electric Griddle
SELECTRONIC ELECTRIC GRIDDLE Commercial & Marine 24S, 24SHE, 24SCHE 36S, 36S-SC, 36SHE 48S, 48SHE, 48SR 60S, 60SHE, 60SR, 60S-SC 72S, 72SR, 72SC Installation and Operation Instructions 2M-W353 Rev. H 1/17/2012 IL1381 48S... - Page 2 CONTROL PANEL. NO USER-SERVICABLE PARTS INSIDE. REPAIRS SHOULD BE DONE BY AUTHORIZED SERVICE PERSONNEL ONLY. NOTICE Using any part other than genuine Lang factory supplied parts relieves the manufacturer of all liability. Lang reserves the right to change specifications and product design without notice. Such revisions do not entitle the buyer to corresponding changes, improvements, additions or replacements for previously purchased equipment.
-
Page 3: Table Of Contents
PROBLEMS, QUESTIONS or CONCERNS Before you proceed consult you authorized Lang service agent directory Call the Lang Technical Service & Parts Department at 314-678-6315. TABLE OF CONTENTS Specifications ......4 - 5 Equipment Description . -
Page 4: Specifications
EQUIPMENT SPECIFICATIONS Height x Width x Depth Clearance from Weight Freight Model (Not including legs) combustible surface Actual Shipping Class 15.0" x 24.0" x 28.2" 243 lbs. 280 lbs. 381mm x 610mm x 717mm 110 kg 127 kg 15.0" x 36.0" x 28.2" 368 lbs. - Page 5 Supply Supply Supply Supply Current Model Volts AC TOT. 1PH. Wire 1 PH Wire 3 PH TOT. 1PH. Wire 1 PH Wire 3 PH 124S 208/240 124S-480V 124SHE 208/240 124SCHE 208/240 136S 208/240 136S-380V 50/60 27.3 27.3 27.3 136S-480V 136SB-WB...
-
Page 6: Equipment Description
EQUIPMENT DESCRIPTION 1” Griddle Surface Rear Gutter (certian models) Gutter Grease Pan Legs IL1548 Main Section Power Switch Section Section Power Switch Temp. Dial Exterior Construction The griddle dimensions are 7” (43.8cm) High, 30” (76.20cm) Deep, and width is dependent on the actual model number. -
Page 7: Unpacking
UNPACKING Receiving the Griddle Upon receipt, check for freight damage, both visible and concealed. Visible damage should be noted on the freight bill at the time of delivery and signed by the carrier’s agent. Concealed loss or damage means it does not become apparent until the merchandise has been unpacked. -
Page 8: Installation
INSTALLATION IL1549 Std Leg Marine Bolt Down Leg Above: typical leg installation. Leg Installation There are four, 4” legs provided for 2, 3 and 2.5” 4 foot griddles. There are eight 4” legs provided for 5 and 6 foot griddles. IL1550 The legs are shipped in the grease drawers of the griddle. -
Page 9: Ventilation & Clearence
2,4,6,8 Re-phasing the griddle is not 160S #1 1,3,5 2,4,6 chargeable to Lang Manufacturing 160S #2 Company as warranty. To convert to single-phase have a Lang 172S #1 1,3,5 2,4,6 Authorized Service Agent, follow 172S #2 1,3,5 2,4,6 this chart. -
Page 10: Initial Start-Up Pre-Power
INITIAL START UP Pre-Power On Before starting the griddle for the first time, clean the griddle body and cooking surface. Use a mild soap and water solution, then rinse with clear water and dry. Power On Set the main power switch, located at the far left of the control panel, to the “ON” (up) position (there are two “ON”... -
Page 11: Operation
OPERATION General The suggested time and temperature chart (below) is provided as a guide for the products listed only. If different temperature settings are to be used, select one side of the griddle and operate at the lowest temperature. Adjoining sections should be set at progressively higher temperatures. Do not try to operate the end sections hot and the center sections cool. - Page 12 MAINTENANCE & CLEANING Cleaning • Always start with a cold griddle. • The stainless exterior can easily be cleaned using a good non-abrasive cleaner. • Always follow the cleaner manufacturer’s instructions when using any cleaner. • Always apply these cleaners when the griddle is cold and rub in the direction of the metal’s grain. Griddle Surface Care (non-chromium surfaces) It takes very little time and effort to keep the griddle attractive and performing at top efficiency.
-
Page 13: Troubleshooting
TROUBLESHOOTING Symptoms What follows is a chart of symptoms and possible causes to aid in diagnosing faults with the griddle. Refer to the Symptoms column to locate the type of failure then to the possible cause for the items to be checked. To test for a possible causes refer to the TEST section and locate the possible cause then refer to test to identify test procedures. - Page 14 TROUBLESHOOTING continued NOTICE: Service on this, or any other, LANG appliance must be performed by qualified personnel only. Consult your Lang Authorized Service Agent Directory or call the factory at 314-678-6315, or WWW.LANGWORLD.COM For the service agent nearest you. BOTH HIGH AND LOW VOLTAGES ARE PRESENT INSIDE THIS APPLIANCE WHEN THE UNIT IS PLUGGED/WIRED INTO A LIVE RECEPTACLE. BEFORE...
- Page 19 CERTAIN INSTANCES MAY NOT BE AVAILABLE This drawing contains information confidential to Star Manufacturing International, Inc. No reproduction or disclosure of it's contents is permitted. Model: 124S - 172S Selectronic Control Electric Griddle LG Electric Griddle Accu-Temp Control SK2263 Rev. C 1/17/12...
-
Page 20: Parts List
PARTS LIST July 24, 202, Rev G Model: 124S, 124S-480V, 124SHE, 124SCHE, Selectronic Electric Griddle FIG NO. PART NO. DESCRIPTION APPLICATION K9-XL-722-15 PLATE ASY 2’ SEL .5 GRV 124S, 124S-480V K9-XL-722-154 PLTEASY 2’ SEL.5GRVW/XLH12 124SHE K9-XL-722-C154 PLT ASSY 2’ SEL .5” GRV CHR... -
Page 21: 380Vm
PARTS LIST July 3, 202, Rev G Model No: 136S, 136S-SC, 136SHE, 136SCHE, 136S-380VM, 136S-480V Selectronic Electric Griddle FIG NO PART NO. DESCRIPTION APPLICATION K9-XL-722-16 PLATE ASY 3’ SEL .5 GRV 136S K9-XL-722-W162 PLATE ASY 3’ SEL.5 GRV CHR 136SC K9-XL-722-164 PLATE ASY 3’SEL .5 GRV 136SHE... - Page 22 PARTS LIST July 24, 202, Rev G Model No: 148S, 148S-480V, 148S-SC, 148S-WB Selectronic Electric Griddle FIG NO PART NO. DESCRIPTION APPLICATION K9-XL-719-4 PLATE ASY 4’SEL REAR GUTR 148S-WB, 148SR K9-XL-722-17 PLATE ASY 4’ SEL .5 GRV 148S K9-XL-722-174 PLTEASY 4’ SEL.5GRVW/XLH12 148SHE-480V 2E-41100-17 TEMP PROBE SEL LG GRIDDLE...
- Page 23 PARTS LIST July 24, 202, Rev G Model No: 160S, 160S-480V, 160S-SC, 160S-WB, 160SHE Selectronic Electric Griddle FIG NO PART NO. DESCRIPTION APPLICATION K9-XL-719-5 PLATE ASY 5’SEL REAR GUTR 160S-WB, 160SR K9-XL-722-18 PLATE ASY 5’ SEL .5 GRV 160S K9-XL-722-184 PLATE ASY 5 GRV W/ XLH12 160SHE 2E-41100-17...
- Page 24 PARTS LIST July 24, 202, Rev G Model No: 172S, 172S-480V, 172S-SC, 172S-480VM Selectronic Electric Griddle FIG NO PART NO. DESCRIPTION APPLICATION K9-XL-722-19 PLATE ASY 6’ SEL .5 GRV 2E-41100-17 TEMP PROBE SEL LG GRIDDLE K9-XL-228 BUCKET SLIDE SUPPORT K9-XL-219-4 BODY ASSEMBLY 3’...
- Page 25 DETAIL Control Panel Assembly (LPGS4-C shown) SK2307 Rev. B 7/7/08...
- Page 26 PARTS LIST May 3, 20, Rev G Detail A: Control Panel Assembly, Selectronic Electric Griddle Model Number Description Control Panel Assembly 124S PNEL XL-LG SEL 2’ 208/240V LGPS2-C-W1 124S-480V PNEL XL-LG SEL 2’ 480V LGPS2-U-W1 124SHE, 148SCHE PNEL SEL 2’ 208/240V W/CSE...
- Page 27 PARTS LIST May 3, 20, Rev G Fig No Part Number Description Control Panel Assembly LGPS2-C, LGPS2-U 2E-30304-22 SWTCB175-450oFW/41100-13 LGPS3-C, LGPS3-U, LGPS3-K LGPS4-C, LGPS4-U, LGPS4-U-W1 LGPS2-C 2J-31601-01 PILOT LT 250V 6LEAD BLK LGPS3-C, LGPS3-U LGPS4-C LGPS2-U 2J-31601-02 PILOT LT 480V 6LEAD BLK LGPS3-U, LGPS3-K LGPS4-U, LGPS4-U-W1 2J-31601-07...
- Page 28 STAR INTERNATIONAL HOLDINGS INC. COMPANY Star - Holman - Lang - Wells - Bloomfield - Toastmaster 10 Sunnen Drive, St. Louis, MO 63143 U.S.A. (314) 678-6303 www.star-mfg.com...